Use Of Two-Dimensional And Three-Dimensional Reactors In Oxidative Electrochemical Degradation Studies Of Malachite Green

Yıl 2024, Cilt: 28 Sayı: 1, 145 - 154, 29.02.2024

Canan Şamdan

https://doi.org/10.16984/saufenbilder.1294817

Öz

With the developments in treatment technologies, including porous materials in electrochemical systems have recently become the focus of researchers' attention. In electrochemical methods, operating cost is as important as efficiency. It is possible to increase the system performance by increasing the effective electrode surface by incorporating activated carbon, which can be produced from biomass, into electrochemical oxidation systems. This study investigated using activated carbon from walnut shells as a microelectrode in the electrochemical oxidative degradation of malachite green. When potential differences between 2V and 4V are applied to 2DES and 3DES reactors containing MG solution, a higher % MG Removal was obtained in 3DES reactors than in 2DES reactors. When the potential difference is 4V, a value of 0.026 (min-1) k1.3D and 0.0117 (min-1) k1.2D are obtained. In 3DES reactors, the rate constant at 0.003 A/cm2 was achieved as 0.0167 (min-1) k1.3D, while at 0.010 A/cm2, it increased by approximately 5 times, reaching a value of 0.0845 min-1 k1.3D. Similarly, in 3DES reactors, when the current density increased from 0.003 A/cm2 to 0.010 A/cm2, the mass transfer rate increased from 0.011 (cm/s) to 0.05633 (cm/s).

Anahtar Kelimeler

Electrochemical Oxidative Degradation, Microelectrodes, Malachite Green

Kaynakça

• [1] Wang, Z., Qi, J., Feng, Y., Li, K., Li, X., “Preparation of Catalytic Particle Electrodes from Steel Slag and Its Performance in a Three-Dimensional Electrochemical Oxidation System,” Journal of Industrial and Engineering Chemistry, vol. 20, no. 5, 2014, pp. 3672–3677.
• [2] Tavares, M. G., Da Silva, L. V. A., Sales Solano, A. M., Tonholo, J., Martínez-Huitle, C. A., Zanta, C. L. P. S., “Electrochemical Oxidation of Methyl Red Using Ti/Ru0.3Ti0.7O2 and Ti/Pt Anodes,” Chemical Engineering Journal, vol. 204–206, 2012, pp. 141–150.
• [3] Isarain-Chavez, E., Baro, M. D., Rossinyol, E., Morales-Ortiz, U., Sort, J., Brillas, E., and Pellicer, E., “Comparative Electrochemical Oxidation of Methyl Orange Azo Dye Using Ti/Ir-Pb, Ti/Ir-Sn, Ti/Ru-Pb, Ti/Pt-Pd and Ti/RuO 2 Anodes,” Electrochimica Acta, vol. 244, 2017, pp. 199–208.
• [4] Zhang, T., Liu, Y., Yang, L., Li, W., Wang, W., Liu, P., “Ti–Sn–Ce/Bamboo Biochar Particle Electrodes for Enhanced Electrocatalytic Treatment of Coking Wastewater in a Three-Dimensional Electrochemical Reaction System,” Journal of Cleaner Production, vol. 258, 2020, p. 120273.
• [5] Xiao, H., Hao, Y., Wu, J., Meng, X., Feng, F., Xu, F., Luo, S., Jiang, B., “Differentiating the Reaction Mechanism of Three-Dimensionally Electrocatalytic System Packed with Different Particle Electrodes: Electro-Oxidation versus Electro-Fenton,” Chemosphere, vol. 325, 2023, p. 138423.
• [6] Shen, B., Wen, X., Huang, X., “Enhanced Removal Performance of Estriol by a Three-Dimensional Electrode Reactor,” Chemical Engineering Journal, vol. 327, 2017, pp. 597–607.
• [7] Sun, Y., Li, P., Zheng, H., Zhao, C., Xiao, X., Xu, Y., Sun, W., Wu, H., Ren, M., “Electrochemical Treatment of Chloramphenicol Using Ti-Sn/γ-Al2O3 Particle Electrodes with a Three-Dimensional Reactor,” Chemical Engineering Journal, vol. 308, pp. 1233–1242, 2017.
• [8] Li, J., Yan, J., Yao, G., Zhang, Y., Li, X., Lai, B., “Improving the Degradation of Atrazine in the Three-Dimensional (3D) Electrochemical Process Using CuFe2O4 as Both Particle Electrode and Catalyst for Persulfate Activation,” Chemical Engineering Journal, vol. 361, pp. 1317–1332, 2019.
• [9] Wang, Y., Cui, C., Zhang, G., Xin, Y., Wang, S., “Electrocatalytic Hydrodechlorination of Pentachlorophenol on Pd-Supported Magnetic Biochar Particle Electrodes,” Separation and Purification Technology, vol. 258, p. 118017, 2021.
• [10] Ren, Y., Wang, J., Qu, G., Ren, N., Lu, P., Chen, X., Wang, Z., Yang, Y., Hu, Y., “Study on the Mechanism of High Effective Mineralization of Rhodamine B in Three Dimensional Electrochemical System with γ-Fe2O3@CNTs Particle Electrodes,” Separation and Purification Technology, vol. 314, p. 123616, 2023.
• [11] Wang, X., Zhao, Z., Wang, H., Wang, F., Dong, W., “Decomplexation of Cu-1-Hydroxyethylidene-1,1-Diphosphonic Acid by a Three-Dimensional Electrolysis System with Activated Biochar as Particle Electrodes,” Journal of Environmental Sciences, vol. 124, pp. 630–643, 2023.
• [12] Zhao, H.-Z., Sun, Y., Xu, L.-N., Ni, J.-R., “Removal of Acid Orange 7 in Simulated Wastewater Using a Three-Dimensional Electrode Reactor: Removal Mechanisms and Dye Degradation Pathway,” Chemosphere, vol. 78, no. 1, pp. 46–51, 2010.
• [13] Chowdhury, S., Saha, P., “Sea Shell Powder as a New Adsorbent to Remove Basic Green 4 (Malachite Green) from Aqueous Solutions: Equilibrium, Kinetic and ermodynamic Studies,” Chemical Engineering Journal, vol. 164, no. 1, pp. 168–177, 2010.
• [14] Kumar, S., Singh, S., Srivastava, V. C., “Electro-Oxidation of Nitrophenol by Ruthenium Oxide Coated Titanium Electrode: Parametric, Kinetic and Mechanistic Study,” Chemical Engineering Journal, vol. 263, pp. 135–143, 2015.
• [15] Al-Shannag, M., Al-Qodah, Z., Bani-Melhem, K., Qtaishat, M. R., Alkasrawi, M., “Heavy Metal Ions Removal from Metal Plating Wastewater Using Electrocoagulation: Kinetic Study and Process Performance,” Chemical Engineering Journal, vol. 260, pp. 749–756, 2015.
• [16] Tonini, G. A., Ruotolo, L. A. M., “Heavy Metal Removal from Simulated Wastewater Using Electrochemical Technology: Optimization of Copper Electrodeposition in a Membraneless Fluidized Bed Electrode,” Clean Technologies and Environmental Policy, no. 2, 2017, pp. 403–415, vol. 19.
• [17] Gottipati, R., Mishra, S., “Preparation of Microporous Activated Carbon from Aegle Marmelos Fruit Shell and Its Application in Removal of Chromium(VI) from Aqueous Phase,” Journal of Industrial and Engineering Chemistry, 2016, pp. 355–363, vol. 36.
• [18] Akbal, F., Camcı, S., “Copper, Chromium and Nickel Removal from Metal Plating Wastewater by Electrocoagulation,” Desalination, vol. 269, no. 1–3, pp. 214–222, 2011.
• [19] Meng, H., Chen, C., Yan, Z., Li, X., Xu, J., Sheng, G., “Co-Doping Polymethyl Methacrylate and Copper Tailings to Improve the Performances of Sludge-Derived Particle Electrode,” Water Research, vol. 165, p. 115016, 2019.