Research Article
BibTex RIS Cite

INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS

Year 2009, Volume: 9 Issue: 3, 273 - 277, 01.12.2009

Aylin Şakar-deliormanli Erdal Çelik Mehmet Polat

Abstract

Drying is a major issue in wet processing ceramics. It has crucial effects on the final properties
ceramics films especially produced by aqueous based tape casting. In this study structural evolution of
ceramic suspension droplets were investigated during drying. Effect of binder concentration on the
ring formation from droplets was tested. Results revealed that PMN:latex ratio have some influence on
the particle migration and at high latex concentrations particle clusters were observed in the
supersaturated region. 

Keywords

Drying tape casting ceramic suspensions

References

  • Meier, P.L., Urech L., and Gauckler, L.J., Tape Casting of Nanocrystallize Ceria Gadolinia Powder, Journal of the European Ceramic Society, Vol. 24, No.15, Pages 3753-3758, 2004.
  • Mistler, R.E., Tape Casting: Past, Present, Potential, American Ceramic Society Bulletin, Vol.77, No.10, Pages 82-86, 1998. .
  • Chiu, R.C. and Cima, M.J., Drying of Granular Ceramic Films: II, Drying Stress, Saturation Uniformity, Journal of the American Ceramic Society, Vol. 76, Pages 2769-2777, 1993.
  • Scherer, G.W., Theory of Drying, Journal of the American Ceramic Society, Vol. 73, No.1, Pages 3-14, 1990.
  • Scherer, G.W., Aging and Drying of Gels, Journal of Non-Crystalline Solids, Vol. 100, Pages 77-92, 1988.
  • Rahaman, M.N., Ceramic Processing and Sintering, (Marcel Dekker Inc., USA), 1995.
  • Lewis, J.A., Colloidal Processing of Ceramics, Journal of the American Ceramic Society, Vol. 83, No.10, Pages 2341-59, 2000.
  • Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Thermal Analysis and Microstructural Characterization of Ceramic Green Tapes Prepared by Aqueous Tape Casting, Journal of Thermal Analysis and Calorimetry, (In press).
  • Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Preparation of the Pb(Mg1/3Nb2/3)O3 Films by Aqueous Tape Casting, Journal of the European Ceramic Society, ( In press).
  • Hu, H., and Larson, R.G., Analysis of the Microfluid Flow in an Evaporating Sessile Droplet, Langmuir, Vol. 21, Pages 3963-3971, 2005.
  • Deegan, R.D., Bakajin, O., Dupont, T.F., Huber, G., Nagel, S.R., and Witten, T.A., Capillary Flow as the Cause of Ring Strains from Dried Liquid Drops, Nature, Vol. 389, Pages 827-829, 1997.
  • Martinez, C.J., Structure and Property Evolution during Film Formation from Binary Colloidal Suspensions, PhD Thesis, University of Illinois at Urbana Champaign, 2002.
  • Martinez, C.J., and Lewis, J., Rheological, Structural, and Stress Evolution of Aqueous Al2O3: Latex Tape Cast Layers, Journal of the American Ceramic Society, Vol. 85, No.10, Pages 2409-16, 2002.

INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS

Year 2009, Volume: 9 Issue: 3, 273 - 277, 01.12.2009

Aylin Şakar-deliormanli Erdal Çelik Mehmet Polat

Abstract

Drying is a major issue in wet processing ceramics. It has crucial effects on the final properties
ceramics films especially produced by aqueous based tape casting. In this study structural evolution of
ceramic suspension droplets were investigated during drying. Effect of binder concentration on the
ring formation from droplets was tested. Results revealed that PMN:latex ratio have some influence on
the particle migration and at high latex concentrations particle clusters were observed in the
supersaturated region. 

Keywords

xx

References

  • Meier, P.L., Urech L., and Gauckler, L.J., Tape Casting of Nanocrystallize Ceria Gadolinia Powder, Journal of the European Ceramic Society, Vol. 24, No.15, Pages 3753-3758, 2004.
  • Mistler, R.E., Tape Casting: Past, Present, Potential, American Ceramic Society Bulletin, Vol.77, No.10, Pages 82-86, 1998. .
  • Chiu, R.C. and Cima, M.J., Drying of Granular Ceramic Films: II, Drying Stress, Saturation Uniformity, Journal of the American Ceramic Society, Vol. 76, Pages 2769-2777, 1993.
  • Scherer, G.W., Theory of Drying, Journal of the American Ceramic Society, Vol. 73, No.1, Pages 3-14, 1990.
  • Scherer, G.W., Aging and Drying of Gels, Journal of Non-Crystalline Solids, Vol. 100, Pages 77-92, 1988.
  • Rahaman, M.N., Ceramic Processing and Sintering, (Marcel Dekker Inc., USA), 1995.
  • Lewis, J.A., Colloidal Processing of Ceramics, Journal of the American Ceramic Society, Vol. 83, No.10, Pages 2341-59, 2000.
  • Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Thermal Analysis and Microstructural Characterization of Ceramic Green Tapes Prepared by Aqueous Tape Casting, Journal of Thermal Analysis and Calorimetry, (In press).
  • Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Preparation of the Pb(Mg1/3Nb2/3)O3 Films by Aqueous Tape Casting, Journal of the European Ceramic Society, ( In press).
  • Hu, H., and Larson, R.G., Analysis of the Microfluid Flow in an Evaporating Sessile Droplet, Langmuir, Vol. 21, Pages 3963-3971, 2005.
  • Deegan, R.D., Bakajin, O., Dupont, T.F., Huber, G., Nagel, S.R., and Witten, T.A., Capillary Flow as the Cause of Ring Strains from Dried Liquid Drops, Nature, Vol. 389, Pages 827-829, 1997.
  • Martinez, C.J., Structure and Property Evolution during Film Formation from Binary Colloidal Suspensions, PhD Thesis, University of Illinois at Urbana Champaign, 2002.
  • Martinez, C.J., and Lewis, J., Rheological, Structural, and Stress Evolution of Aqueous Al2O3: Latex Tape Cast Layers, Journal of the American Ceramic Society, Vol. 85, No.10, Pages 2409-16, 2002.
There are 13 citations in total.

Details

Primary Language English
Subjects Engineering
Journal Section Articles
Authors

Aylin Şakar-deliormanli This is me

Erdal Çelik This is me

Mehmet Polat This is me

Publication Date December 1, 2009
Submission Date August 8, 2015
Published in Issue Year 2009 Volume: 9 Issue: 3

Cite

APA Şakar-deliormanli, A., Çelik, E., & Polat, M. (2009). INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi, 9(3), 273-277.
AMA Şakar-deliormanli A, Çelik E, Polat M. INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi. December 2009;9(3):273-277.
Chicago Şakar-deliormanli, Aylin, Erdal Çelik, and Mehmet Polat. “INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS”. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi 9, no. 3 (December 2009): 273-77.
EndNote Şakar-deliormanli A, Çelik E, Polat M (December 1, 2009) INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi 9 3 273–277.
IEEE A. Şakar-deliormanli, E. Çelik, and M. Polat, “INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS”, Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi, vol. 9, no. 3, pp. 273–277, 2009.
ISNAD Şakar-deliormanli, Aylin et al. “INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS”. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi 9/3 (December 2009), 273-277.
JAMA Şakar-deliormanli A, Çelik E, Polat M. INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi. 2009;9:273–277.
MLA Şakar-deliormanli, Aylin et al. “INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS”. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi, vol. 9, no. 3, 2009, pp. 273-7.
Vancouver Şakar-deliormanli A, Çelik E, Polat M. INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen Ve Mühendislik Bilimleri Dergisi. 2009;9(3):273-7.