Methane yield of paper industry waste in the presence of two compounds from alcohol and aldehyde groups during thermophilic anaerobic digestion

Yıl 2023, Cilt: 6 Sayı: 1, 54 - 59, 31.03.2023

Eda Yarsur İlona Horvath Cigdem Yangin-gomec

https://doi.org/10.35208/ert.1212911

Öz

In this study, effect of two chemical compounds (i.e., 1-octanol and hexanal) respectively from the alcohol and aldehyde groups on thermophilic (55±2 °C) anaerobic process digesting the waste produced at a paper industry was investigated. In this scope, possible inhibition was monitored by the cumulative methane (CH4) yields in the batch reactors digesting the paper waste as the feedstock at concentrations of 0.005%, 0.05%, and 0.5% for each compound. Comparing the effects of the two different groups with the control reactor having only the paper waste as the substrate, the results revealed that adding 1-octanol and hexanal up to 0.05% concentrations had some synergistic effect on biogas yield (i.e., from 3% to 12% enhancement). Accordingly, the highest methane yields were 550 and 567 mL/g-VSfed, respectively on average in the presence of 1-octanol and hexanal at a concentration of 0.05% while the cumulative methane yield was observed as 490 mL/g-VSfed for the control reactor. With the exception of 1-octanol at 0.5%, adding both compounds at each investigated concentration was beneficial for the digestion in the batch process. Therefore, the selected alcohol and aldehyde sources did not cause the expected detrimental effect on the methanogens even at the maximum amounts added in this study. Nevertheless, since the effect of the chemical compounds on methane generation has been generally concentration-dependent, the toxic effects of 1-octanol and hexanal would be better observed at higher concentrations (>0.5%), especially when their threshold levels are exceeded in anaerobic reactors digesting paper wastes.

Anahtar Kelimeler

1-octanol, biogas, hexanal, inhibition, lignocellulose

Destekleyen Kurum

Department of Scientific Research Projects of ITU

Proje Numarası

MYL-2019-42365

Teşekkür

The authors are also grateful for former PhD student, Vanessa Elisa Pinheiro, for all practical help in the lab at the Swedish Centre for Resource Recovery, at University of Borås.

Kaynakça

• Y. Li, S. Y. Park, and J. Zhu, “Solid-state anaerobic digestion for methane production from organic waste,” Renew Sust Energ Rev., Vol. 15, pp. 821–826, 2011.
• J. Yi, B. Dong, J. Jin, and X. Dai, “Effect of increasing total solids contents on anaerobic digestion of food waste under mesophilic conditions: performance and microbial characteristics analysis,” PLoS One., Vol. 9, pp. e102548, 2014.
• A.T. Jansson, R.J. Patinvoh, M.J. Taherzadeh, and I. Sárvári Horváth, “Effect of organic compounds on dry anaerobic digestion of food and paper industry wastes,” Bioengineered, Vol. 11, pp. 502-509, 2020.
• T. Meyer, and E.A. Edwards, “Anaerobic digestion of pulp and paper mill wastewater and sludge,” Water Research, Vol. 65, pp. 321-349, 2014.
• S. Lacorte, A. Latorre, D. Barceló, A. Rigol, A. Malmqvist, and T. Welander, “Organic compounds in paper-mill process waters and effluents,” TrAC Trends in Analytical Chemistry, Vol. 22, pp. 725-737, 2003.
• I. Alam, and C. Sharma, “Degradation of paper products due to volatile organic compounds,” Preprint (Version 1) available at Research Square [https://doi.org/10.21203/rs.3.rs-2080804/v1], 2022.
• A. Nsair, S. Onen Cinar, A. Alassali, H. Abu Qdais, and K. Kuchta, “Operational parameters of biogas plants: A review and evaluation study,” Energies, Vol. 13, pp. 3761, 2020.
• C. Yangin-Gomec, T. Sapmaz, and S. Aydin, “Impact of inoculum acclimation on energy recovery and investigation of microbial community changes during anaerobic digestion of the chicken manure,” Environmental Technology, Vol. 41, pp. 49–58, 2020.
• H. Yanti R. Wikandari, R. Millati, C. Niklasson, and M.J. Taherzadeh, “Effect of ester compounds on biogas production: beneficial or detrimental?” Energy Sci Eng., Vol. 2, pp. 22–30, 2014.
• A. Fagerlund, D. Shanks, K. Sunnerheim, L. Engman, and H. Frisell, “Protective effects of synthetic and naturally occurring antioxidants in pulp products,” Nordic Pulp & Paper Research Journal, Vol. 18, pp. 176-181, 2003.
• H. Lindell, Odour and Taste Originating from Food Packaging Board, C.F. Baker, Ed. Products of Papermaking, Trans. of the Xth Fund. Res. Symp. Oxford, Manchester: FRC, pp. 431–497, 2018.
• https://pubchem.ncbi.nlm.nih.gov/compound/1-Octanol, National Center for Biotechnology Information (NCBI) website. [Online]. Available: (2020)
• R. Domínguez, M. Pateiro, M. Gagaoua, F.J. Barba, W. Zhang, and J. M. Lorenzo, “A comprehensive review on lipid oxidation in meat and meat products,” Antioxidants, Vol. 8, pp. 429, 2019.
• Q. Chang, Emulsion, Foam, and Gel, Q. Chang, Ed. Colloid and Interface Chemistry for Water Quality Control, Chapter 11, Academic Press, pp. 227-245, 2016.
• C. Yangin-Gomec, E. Yarsur, and O.Y. Ozcan, “Energy recovery during anaerobic treatment of lignocellulosic wastewater with dynamic modeling and simulation results,” Biomass Conv. Bioref., 2021. https://doi.org/10.1007/s13399-021-01757-7
• E. Yarsur, “Biogas recovery during anaerobic treatment of lignocellulose-rich pollutants with high sulfate content: an investigation via innovative applications,” M. Eng. Thesis, Istanbul Technical University, Istanbul, Turkey, Feb. 2021.
• https://pubchem.ncbi.nlm.nih.gov/compound/Hexanal, National Center for Biotechnology Information (NCBI) website. [Online]. Available: (2020)
• Standard Methods for the Examination of Water and Wastewater, 21st ed., American Public Health Association (APHA) Press, Washington, United States, 2005.
• A. Teghammar, J. Yngvesson, M. Lundin, M.J. Taherzadeh, and I. Sárvári Horváth, “Pretreatment of paper tube residuals for improved biogas production,” Bioresour Technol., Vol. 101, pp. 1206-1212, 2010.
• R. Sierra-Alvarez, and G. Lettinga, “The effect of aromatic structure on the inhibition of acetoclastic methanogenesis in granular sludge,” Appl. Microbiol. Biotechnol., Vol. 34, pp. 544–550, 1991.
• M. Qu, and S.K. Bhattacharya, “Toxicity and biodegradation of formaldehyde in anaerobic methanogenic culture,” Biotechnol. Bioeng., Vol. 55, pp. 727-736, 1997.
• G.N. Demirer, and R.E. Speece, “Anaerobic biotransformation of four3-carbon compounds (acrolein, acrylic acid, allyl alcohol and n-propanol) in UASB reactors,” Water Res., Vol. 32, pp. 747–759, 1998.
• A.T. Jansson, R.J. Patinvoh, I. Sárvári Horváth, and M.J. Taherzadeh, “Dry anaerobic digestion of food and paper industry wastes at different solid contents,” Fermentation, Vol. 5, pp. 40, 2019.
• J.N. Meegoda, B. Li, K. Patel, and L.B. Wang, “A review of the processes, parameters, and optimization of anaerobic digestion,” Int J Environ Res Public Health, Vol. 15, pp. 2224, 2018.