Heat transfer analysis of hybrid active solar still with water flowing over glass cover

Year 2021, , 1329 - 1343, 02.09.2021

Manoj Kumar Gaur Gopal N Tiwari Pushpendra Sıngh Anand Kushwah

https://doi.org/10.18186/thermal.989993

Cited By: 1

Abstract

The aim of this research is to carry out the heat transfer analysis of PVT hybrid active solar still (HASS) at different water depth to obtain maximum output. Experimentation is performed for validation of thermal modeling with and without flowing water, having water depth of 0.15m in the solar still basin. During experimentation, water flows above the glass cover. Theoretically calculated values of basin water, basin liner, glass temperature and yield obtained using thermal modeling are very near to the experimental values having correlation coefficients 0.988, 0.981, 0.999 and 0.985 respectively. It is also found that thermal efficiency and daily exergy output increases by 4% and 8.2% respectively for this hybrid system whose glass cover is getting cooled by water flowing over it. Theoretical calculation for distillate output of the system was also calculated out for various climatic conditions of India using developed thermal modeling and it is found that proposed system gives higher annual yield of 2756.67 kg/m2 for the climate of Mumbai. The experimental uncertainty of the HASS is obtained as 14.82%.

Keywords

PVT collector, Hybrid active solar still, Thermal Modeling, Thermal efficiency

References

• [1] Yousef MS, Hassan H, Sekiguchi H. Energy, exergy, economic and enviroeconomic (4E) analyses of solar distillation system using different absorbing materials. Appl Therm Eng 2019;150:30–41. [CrossRef]
• [2] Taner T, Dalkilic AS. A feasibility study of solar energy-techno economic analysis from Aksaray city, Turkey. J Therm Eng 2019;5:25–30. [CrossRef]
• [3] Gurupatham SK, Manikandan GK, Fahad F. Harnessing and storing solar thermal energy using phase change material (PCM) in a small flat plate collector. J Therm Eng 2020;6:511–20. [CrossRef]
• [4] Mahian O, Kianifar A, Jumpholkul C, Thiangtham P, Wongwises S, Srisomba R. Solar Distillation Practice For Water Desalination Systems. J Therm Eng 2015;1:287. [CrossRef]
• [5] Mohamed AF, Hegazi AA, Sultan GI, El-Said EMS. Augmented heat and mass transfer effect on performance of a solar still using porous absorber: Experimental investigation and exergetic analysis. Appl Therm Eng 2019;150:1206–15. [CrossRef]
• [6] Bait O. Exergy, environ–economic and economic analyses of a tubular solar water heater assisted solar still. J Clean Prod 2019;212:630–46. [CrossRef]
• [7] Telkes M. Improved Solar Stills. Trans Conf Use Sol Energy. Sci Basis, Tuscon Arizona, Vol. 3, October 31- November 1: 1955:145–53 (Chapter 14, part 2).
• [8] Cooper PI. Digital simulation of transient solar still processes. Sol Energy 1969;12:313–31. [CrossRef]
• [9] Cooper PI. The maximum efficiency of single-effect solar stills. Sol Energy 1973;15:205–17. [CrossRef]
• [10] Dunkle RV. Solar water distillation: the roof type still and a multiple effect diffusion still. Int Heat Transf Conf Colorado, USA. 1961:895–902.
• [11] Rahbar N, Esfahani JA. Productivity estimation of a single-slope solar still: Theoretical and numerical analysis. Energy 2013;49:289–97. [CrossRef]
• [12] Malik MAS, Tiwari GN, Kumar A, Sodha MS. Solar Distillation: A Practical Study of a Wide Range of Stills and Their Optimum Design, Construction and Performance. 1st ed. Newyork: Pergamon Press, Oxford; 1982.
• [13] Tiwari GN, Tiwari A. Solar distillation practice in water desalination systems. Tunbridge Wells, UK: Anshan; 2008.
• [14] Kumar S, Tiwari GN. Performance evaluation of an active solar distillation system. Energy 1996;21:805–8. [CrossRef]
• [15] Sanjeev K, Tiwari GN. Optimization of daily yield for an active double effect distillation with water flow. Energy Convers Manag 1999;40:703–15. [CrossRef]
• [16] Zurigat YH, Abu-Arabi MK. Modelling and performance analysis of a regenerative solar desalination unit. Appl Therm Eng 2004;24:1061–72. [CrossRef]
• [17] Sinha S, Kumar. Sanjay. Theoretical evaluation of air regenerative solar distiller integrated with aspirator. Renew Energy 1994;4:311-8. https://doi.org/10.1016/0960-1481(94)90034–5.
• [18] Prakash J, Kavathekar AK. Performance prediction of a regenerative solar still. Sol Wind Technol 1986;3:119–25. [CrossRef]
• [19] Tiwari GN, Sinha S. Parametric studies of active regenerative solar still. Energy Convers Manag 1993;34:209–18. [CrossRef]
• [20] Lawrence SA, Gupta SP, Tiwari GN. Effect of Heat capacity on the performance of solar still with water flow over the glass cover. Energy Convers Manag 1990;30:277–85. [CrossRef]
• [21] Singh AK, Tiwari GN. Thermal evaluation of regenerative active solar distillation under thermosyphon mode. Energy Convers Manag 1993;34:697–706. [CrossRef]
• [22] Abu-Hijleh BAK. Enhanced solar still performance using water film cooling of the glass cover. Desalination 1996;107:235–44. [CrossRef]
• [23] Wibulswa P, Tadtiam S. Improvement of a basin type solar still by means of vertical back wall. Int. Symp. Work. Renew. Energy Sources, Lahore: 1984.
• [24] Kudish AI. Water desalination. In: Parker BF, editor. Sol Energy Agric. Amsterdam: Elsevier; 1991:255–94 (Chapter 8).
• [25] Wibulswa P, Suntrirat S. No Title. Int. Symp. Work. Renew. Energy Sources, Lahore: 1984.
• [26] Gugulothu R, Somanchi NS, Reddy KVK, Gantha D. A Review on Solar Water Distillation Using Sensible and Latent Heat. Procedia Earth Planet Sci 2015;11:354–60. [CrossRef]
• [27] Tiwari GN, Madhuri. Effect of water depth on daily yield of the still. Desalination 1987;61:67–75. [CrossRef]
• [28] Tsilingiris PT. Theoretical derivation and comparative evaluation of mass transfer coefficient modeling in solar distillation systems - The Bowens ratio approach. Sol Energy 2015;112:218–31. [CrossRef]
• [29] Kumar S, Tiwari GN. Estimation of internal heat transfer coefficients of a hybrid (PV/T) active solar still. Sol Energy 2009;83:1656–67. [CrossRef]
• [30] Kumar S, Tiwari A. An experimental study of hybrid photovoltaic thermal (PV/T)-active solar still. Int J Energy Res 2008;32:847–58. [CrossRef]
• [31] Gaur MK, Tiwari GN. Optimization of number of collectors for integrated PV/T hybrid active solar still. Appl Energy 2010;87:1763–72. [CrossRef]
• [32] Singh DB, Tiwari GN. Performance analysis of basin type solar stills integrated with N identical photovoltaic thermal (PVT) compound parabolic concentrator (CPC) collectors: A comparative study. Sol Energy 2017;142:144–58. [CrossRef]
• [33] Kabeel AE, Abdelgaied M. Observational study of modified solar still coupled with oil serpentine loop from cylindrical parabolic concentrator and phase changing material under basin. Sol Energy 2017;144:71–8. [CrossRef]
• [34] El-Sebaii AA, El-Naggar M. Year round performance and cost analysis of a finned single basin solar still. Applied Thermal Engineering 2017;110:787–94. [CrossRef]
• [35] Muthu Manokar A, Prince Winston D, Kabeel AE, El-Agouz SA, Sathyamurthy R, Arunkumar T, et al. Integrated PV/T solar still- A mini-review. Desalination 2018;435:259–67. [CrossRef]
• [36] Boubekri M, Chaker A, Cheknane A. Modeling and simulation of the continuous production of an improved solar still coupled with a photovoltaic/thermal solar water heater system. Desalination 2013;331:6–15. [CrossRef]
• [37] Singh HN, Tiwari GN. Monthly performance of passive and active solar stills for different Indian climatic conditions. Desalination 2004;168:145–50. [CrossRef]
• [38] Arunkumar T, Kabeel AE, Raj K, Denkenberger D, Sathyamurthy R, Ragupathy P, et al. Productivity enhancement of solar still by using porous absorber with bubble-wrap insulation. J Clean Prod 2018;195:1149–61. [CrossRef]
• [39] Dubey S, Tiwari GN. Thermal modeling of a combined system of photovoltaic thermal (PV/T) solar water heater. Sol Energy 2008;82:602–12. [CrossRef]
• [40] Hepbasli A. A key review on exergetic analysis and assessment of renewable energy resources for a sustainable future. Renew Sustain Energy Rev 2008;12:593–661. [CrossRef]
• [41] Petela R. Exergy of undiluted thermal radiation. Sol Energy 2003;74:469–88. [CrossRef]
• [42] Kumar S, Tiwari GN. Estimation of convective mass transfer in solar distillation systems. Sol Energy 1996;57:459–64. [CrossRef]