An Experimentally Investigation Of Usability Of A Blend Of Tallow Methyl Ester And Diesel Fuel Substitution Of Diesel Fuel In Diesel Engines

Abstract

Biodiesel fuels is one of the most attractive alternative fuels to reduce both emissions and petroleum based fuel consumption resulted from diesel engines. Therefore, the effects of biodiesel fuels on long-term engine operation and deposits in engine are considerably important, when biodiesel was evaluated as the alternative fuel for diesel engines. In this study, a 100 h engine test was performed on a single cylinder diesel engine using diesel fuel and tallow methyl ester as biodiesel fuel in order to compare the effects of the fuels on engine operation and deposits. The biodiesel was blended with 80 vol% diesel fuel and 20 vol % tallow methyl ester. Also, short-term engine performance and emissions were investigated and compared using both fuels. The test engine was disassembled before and after the experiment to determine the difference and clean carbon deposits. Experimental results were similar for both fuels in long-term engine tests, and indicated that the engine was satisfactorily operated for 100 hours with blend fuel. Deposits in engine at the end of the 100 h test were comparable in amount, but slightly different in color and adhesive, with the blend fuel when compared with those of diesel fuel. Besides, the blend fuel was comparable with the performance of diesel fuel and the exhaust emissions were lower than that of diesel fuel. It is concluded at the results of engine tests; the blend fuel can be a suitable alternative fuel for diesel engines to substitute diesel.

 

Key Words: Tallow methyl ester; Engine deposits; performance and emissions.

Keywords

• Tallow methyl ester, Engine deposits, performance and emissions

Diesel Fuel In Diesel Engines

Abstract

References

1. Yang, H.H., et al. “Effects of biodiesel on emissions of regulated hydrocarbons under engine durability testing”, Atmospheric Environment, 41:7232–7240 (2007). aromatic
2. Ali, Y. and Hanna, M.A., “Durability Testing of a Diesel Fuel, Methyl Tallowate and Ethanol Blend in a Cummins N14-410 www.biodiesel.org/resources/reportsdatabase /reports /tra / 19960101_tra-035.pdf Engine”,
3. Agarwal, A K., “Experimental investigations of the effect of biodiesel utilization on lubricating oil tribology in diesel engines”, Engineering, 219(5):703-713 (2005). of Automobile
4. Pehan, P., Jerman, MS., Kegl, M., Kegl, B., “Biodiesel influence on tribology characteristics of a diesel engine”, Fuel, 88:970–979. (2009).
5. Agarwal, AK. “Biofuels (alcohols and biodiesel) applications as fuels for internal combustion engines” , Progress in Energy and Combustion Science, 33:233–271. (2007).
6. Çelik, İ. Şenöğüt, C. Aydın, O. “Usage of Biodiesel as Fuel and Examining Its Effects on an Engine”, Energy Sources, Part A, 31:1857–1865. (2009).
7. Altun, Ş., “Experimental Investigation of its Use in a Diesel Engine and Bio-Fuel Production From Animal Fats”, PhD Thesis, Graduate School of Natural and Applied Sciences, Fırat University, Turkey, 137 (2009)
8. Graboski, M.S. and Mccormick, R.L., “Combustion of Fat and Vegetable Oil Derived Fuels in Diesel Engine”, Progress in Energy and Combustion Science, 24, 125-164. (1998).

9. Clark, S.J., Wagner, L., Schrock, M.D., Piennaar, P.G., “Methyl and Ethyl Soybean Esters as Renewable Fuels for Diesel Engines”, JAOCS, 61(10): 1632 (1984).
10. Wyatt, V.T., Hess, M.A., Dunn, R.A., Foglia, T.A., Haas, A.J. and Marmer, W.N., “Fuel Properties and Nitrogen Oxide Emission Levels of Biodiesel Produced from Animal Fats”, JAOCS, 82(8):585-591 (2005).
11. Mittelbach, M., “Diesel Fuel Derived from Vegetable Oils, VI: Specifications and Quality Control of Biodiesel”, Bioresource Technology, 56:7–11 (1996).
12. Altun, Ş., Bulut, H., Öner, C., The Comparison of Engine Performance and Exhaust Emission Characteristics of Sesame Oil-Diesel Fuel Mixture with Diesel Fuel in a Direct Injection Diesel Engine, Renewable Energy, 33(8):1741-1745 (2008).
13. Yücel, H.L., Pamuk Yağının Alternatif Dizel Yakıtı Olarak Kullanılması, Science and Eng. J of Fırat Univ. 20 (1):185- 192 (2008). (in Turkish).
14. Devan, PK, Mahalakshmi, NV, Performance, emission and combustion characteristics of poon oil and its diesel blends in a DI diesel engine, Fuel, 88(5):861-867 (2009).
15. Murayama Tadashi, Oh Toung-taig, Miyamoto Noboru, Chikahisa Takemi. Low carbon flower buildup, low smoke, and efficient diesel operation with vegetable oils by conversion to mono-esters and blending with diesel oil or alcohols. SAE paper No. 841161. [16] Çanakçı, M., Combustion
16. Characteristics of a
17. Turbocharged DI Compression Ignition Engine Fuelled
18. with Petroleum Diesel Fuels and Biodiesel, Bioresource
19. Technology, 98:1167–1175 (2007).
20. Yücesu, H. S., İlkılıç, C., Effect of Cotton Seed Oil Methyl Esther on the Performance and Exhaust Emission of a Diesel Engine, Energy Sources, Part: A, 28:389-398 (2006).
21. Keskin A, Gürü, M., Altıparmak D, Aydın, K., Using of cotton oil soap stock biodiesel–diesel fuel blends as an alternative diesel fuel, Renewable Energy, 33:553–557 (2008).
22. Lapuerta, M., Fernandez, J.D., Oliva, F., and Canoira, L., Biodiesel from Low-Grade Animal Fats: Diesel Engine Performance and Emissions, Energy & Fuels, 23:121–129 (2009).
23. Ozsezen, AN., Çanakçı, M., Türkcan, A. Sayın, C. Performance and combustion characteristics of a DI diesel engine fueled with waste palm oil and canola oil methyl esters, Fuel 88:629–636 (2009).
24. İçingür, Y., Altıparmak, D., Effect of fuel cetane number and injection pressure on a DI Diesel engine performance and emissions, Energy Conversion and Management, 44:389–397 (2003). [22] Rainbow LA186, Engine Technical Specification Handbook.