Kömürlü Termik Santrallerde Kazan Verimsizliğinin Seviyelendirilmiş Elektrik Maliyetine Etkisi Üzerine Bir İnceleme

Abstract

Bu çalışmada, Afşin–Elbistan B Termik Santralinde tesisin olan SR EPOS (Energy Optimization System) sisteminden elde edilen veriler kullanılarak termo-ekonomik analiz gerçekleştirilmiştir. Tesisin seviyelendirilmiş elektrik maliyeti (SEM), üç farklı senaryo üzerinden hesaplanmış ve kazanın tasarım değerlerine dayalı olarak hesaplanan verim ile EPOS sisteminden elde edilen gerçek verilerle belirlenen verimler arasındaki farklar, üretici tarafından sağlanan referans verim ile karşılaştırılmıştır. Bu karşılaştırma sonucunda, verim farklılıklarının SEM üzerindeki etkisi analiz edilmiştir. Kazan verimindeki sapmadan kaynaklanan ve tesisin ekonomik ömrünün 20 yıl olduğu kabulüyle hesaplanan SEM farkın 100 milyon USD seviyelerine ulaşabildiğini göstermektedir.

Keywords

• Termo-ekonomik analiz
• Seviyelendirilmiş elektrik maliyeti (LCOE-SEM)
• Enerji optimizasyon sistemi (EPOS)
• Kazan verimi
• Gerçek zamanlı performans analizi
• Termik santral ekonomisi

A Study on the Effect of Boiler Inefficiency on Levelized Electricity Cost in Coal-Fired Thermal Power Plants

Abstract

In this study, thermo-economic analysis was performed using data obtained from the SR EPOS (Energy Optimization System) system of the Afşin–Elbistan B Thermal Power Plant. The levelized electricity cost (LEC) of the plant was calculated over three different scenarios and the differences between the efficiency calculated based on the design values ​​of the boiler and the efficiencies determined by the actual data obtained from the EPOS system were compared with the reference efficiency provided by the manufacturer. As a result of this comparison, the effect of the efficiency differences on the LEC was analyzed. The LEC, which is calculated by assuming that the economic life of the plant is 20 years and caused by the deviation in the boiler efficiency, shows that the difference can reach 100 million USD.

Keywords

• Thermo-economic analysis
• Levelized cost of electricity (LCOE-SEM)
• Energy optimization system (EPOS)
• Boiler efficiency
• Real-time performance analysis
• Thermal power plant economy

References

1. [1] Kaushik, S. C. , Reddy, V. S. , Tyagi, S. K. , “Energy and exergy analyses of thermal power plants: A review”, Renewable and Sustainable Energy Reviews , 15: 1857-1872 (2011)
2. [2] da Silva, J. A. M. , ´Avila Filho, S. , Carvalho, M. , 2017. Assessment of energy and exergy efficiencies in steam generators. J. Braz. Soc. Mech. Sci. Eng. 39 (8), 3217–3226. https://doi. org/10. 1007/s40430-016-0704-6.
3. [3] Ibrahim, T. K. , et al. , 2018. A comprehensive review on the exergy analysis of combined cycle power plants. Renew. Sustain. Energy Rev. 90 (March), 835–850. https://doi. org/10. 1016/j. rser. 2018. 03. 072.
4. [4] Abdelrazik, A. S. , et al. , 2022. The recent advancements in the building integrated photovoltaic/thermal (BIPV/T) systems: an updated review. Renew. Sustain. Energy Rev. 170 https://doi. org/10. 1016/j. rser. 2022. 112988
5. [5] Abdelrazik, A. S. , et al. , 2023. ANSYS-fluent numerical modeling of the solar thermal and hybrid photovoltaic-based solar harvesting systems. J. Therm. Anal. Calorim. https://doi. org/10. 1007/s10973-023-12509-2.
6. [6] Guo, X. , Sun, J. , Ha, W. , 2023. Proposal and 4E analysis of an innovative integrated model based on A gas turbine cycle for the simultaneous production of power, methanol, desalinated water, and heating. Process Saf. Environ. Prot. 178 (August), 156–175. https://doi. org/10. 1016/j. psep. 2023. 08. 022.
7. [7] Tavana, M. , et al. , 2023. Realistic energy, exergy, and exergoeconomic (3E) characterization of a steam power plant: multi-criteria optimization case study of mashhad tous power plant. Water (Switz. ) 15 (17). https://doi. org/10. 3390/ w15173039.
8. [8] Khaleel, O. J. , et al. , 2022. Energy and exergy analysis of the steam power plants: a comprehensive review on the classification, development, improvements, and configurations. Ain Shams Eng. J. 13 (3), 101640 https://doi. org/10. 1016/j. asej. 2021. 11. 009

9. [9] Ahmadi, P. , Dincer, I. , Rosen, M. A. , “Exergy, exergoeconomic and environmental analyses and evolutionary algorithmbased multi-objective optimization of combined cycle power plants”, Energy, 36: 5886-5898 (2011)
10. [10] Kaushik, S. C. , Reddy, V. S. , Tyagi, S. K. , 2011. Energy and exergy analyses of thermal power plants: a review. Renew. Sustain. Energy Rev. 15 (4), 1857–1872. https://doi. org/10. 1016/j. rser. 2010. 12. 007.
11. [11] Kumar, R. , 2017. A critical review on energy, exergy, exergoeconomic and economic (4- E) analysis of thermal power plants. Eng. Sci. Technol. , Int. J. 20 (1), 283–292. https://doi. org/10. 1016/j. jestch. 2016. 08. 018.
12. [12] Ahmadi, M. H. , et al. , 2019. Thermodynamic and economic analysis of performance evaluation of all the thermal power plants: a review. Energy Sci. Eng. 7 (1), 30–65. https://doi. org/10. 1002/ese3. 223.
13. [13] Tahir, M. F. , Haoyong, C. , Guangze, H. , 2021. A comprehensive review of 4E analysis of thermal power plants, intermittent renewable energy and integrated energy systems. Energy Rep. 7, 3517–3534. https://doi. org/10. 1016/j. egyr. 2021. 06. 006.
14. [14] Elwardany, M. , Nassib, A. M. , Mohamed, H. A. , 2024. Analyzing global research trends in combined cycle power plants: a bibliometric study. Energy Nexus 13 (2023), 100265. https://doi. org/10. 1016/j. nexus. 2023. 100265.
15. [15] Khaleel, O. J. , et al. , 2022. Energy and exergy analysis of the steam power plants: a comprehensive review on the classification, development, improvements, and configurations. Ain Shams Eng. J. 13 (3), 101640 https://doi. org/10. 1016/j. asej. 2021. 11. 009
16. [16] Regulagadda, P. , Dincer, I. , Naterer, G. F. , 2010. Exergy analysis of a thermal power plant with measured boiler and turbine losses. Appl. Therm. Eng. 30 (8–9), 970–976. https://doi. org/10. 1016/j. applthermaleng. 2010. 01. 008.
17. [17] Ahmadi, G. R. , Toghraie, D. , 2016. Energy and exergy analysis of montazeri steam power plant in Iran. Renew. Sustain. Energy Rev. 56, 454–463. https://doi. org/10. 1016/j. rser. 2015. 11. 074.
18. [18] Singh, O. K. , Kaushik, S. C. , 2013. Variables influencing the exergy based performance of a steam power plant. Int. J. Green. Energy 10 (3), 257–284. https://doi. org/10. 1080/ 15435075. 2011. 653847.
19. [19] Pattanayak, L. , Sahu, J. N. , 2015. Steady state modeling on energy and exergy analysis of a pulverized coal fired thermal power plant. Asia Pac. J. Chem. Eng. 10 (6), 876–884. https://doi. org/10. 1002/apj. 1924.
20. [20] Vanithasri, M. , Balamurugan, R. , Lakshminarasimman, L. , 2016. Modified radial movement optimization (MRMO) technique for estimating the parameters of fuel cost function in thermal power plants. Eng. Sci. Technol. , Int. J. 19 (4), 2035–2042. https://doi. org/10. 1016/j. jestch. 2016. 07. 012.
21. [21] Wang, C. , et al. , 2018. Dynamic modeling and operation optimization for the cold end system of thermal power plants during transient processes. Energy 145, 734–746. https://doi. org/10. 1016/j. energy. 2017. 12. 146.
22. [22] Wang, L. , et al. , 2016. Multi-objective superstructure-free synthesis and optimization of thermal power plants. Energy 116, 1104–1116. https://doi. org/10. 1016/j. energy. 2016. 10. 007.
23. [23] Kler, A. M. , Potanina, Y. M. , Marinchenko, A. Y. , 2020. Co-optimization of thermal power plant flowchart, thermodynamic cycle parameters, and design parameters of components. Energy 193, 116679. https://doi. org/10. 1016/j. energy. 2019. 116679.
24. [24] Kurklu, K. , Sayilgan, E. , 2020. Optimization of major elements recovery from thermal power plant fly ash using Taguchi experimental design. Int. J. Environ. Sci. Technol. 17 (5), 2645–2654. https://doi. org/10. 1007/s13762-020-02666-4.
25. [25] R. P, Praveen, 2020. Performance analysis and optimization of central receiver solar thermal power plants for utility scale power generation. Sustain. (Switz. ) 12 (1). https://doi. org/10. 3390/SU12010127.
26. [26] Turkin, A. N. , Vasil’ev, V. A. , 2020. Optimization of losses in the shaft-end seals of high-power feedwater pumps of thermal power plants. Power Technol. Eng. 53 (5), 591–596. https://doi. org/10. 1007/s10749-020-01121-1.
27. [27] Sharma, R. K. , Mohapatra, S. K. , 2016. Thermo-economic analysis of a biomass-fired bubbling fluidised bed thermal power plant. Int. J. Exergy 21 (1), 1–20. https://doi. org/10. 1504/IJEX. 2016. 078504.
28. [28] Risthaus, K. , Madlener, R. , 2017. Economic analysis of electricity storage based on heat pumps and thermal storage units in large-scale thermal power plants. Energy Procedia 142, 2816–2823. https://doi. org/10. 1016/j. egypro. 2017. 12. 427.
29. [29] Khajepour, S. , Ameri, M. , 2020. Techno-economic analysis of using three Fresnel solar fields coupled to a thermal power plant for different cost of natural gas. Renew. Energy 146, 2243–2254. https://doi. org/10. 1016/j. renene. 2019. 08. 075.
30. [30] Cheng, L. , Sun, Y. P. , Wen, T. L. , 2023. Economic analysis on reform of flue gas waste heat utilization system in thermal power plant. Environmental Science and Engineering. Springer International Publishing. https://doi. org/10. 1007/978-3-031-30233-6_13.
31. [31] Ogorure, O. J. , et al. , 2018. Energy, exergy, environmental and economic analysis of an agricultural waste-to-energy integrated multigeneration thermal power plant. Energy Convers. Manag. 171, 222–240. https://doi. org/10. 1016/j. enconman. 2018. 05. 093.
32. [32] Owebor, K. , et al. , 2019. Thermo-environmental and economic analysis of an integrated municipal waste-to-energy solid oxide fuel cell, gas-, steam-, organic fluid- and absorption refrigeration cycle thermal power plants. Appl. Energy 239 (February), 1385–1401. https://doi. org/10. 1016/j. apenergy. 2019. 02. 032.
33. [33] Lin, X. , et al. , 2020. Thermo-economic analysis of typical thermal systems and corresponding novel system for a 1000 MW single reheat ultra-supercritical thermal power plant. Energy 201, 117560. https://doi. org/10. 1016/j. energy. 2020. 117560.
34. [34] Fan, Xuezhou, et al. , 2023. Geothermal assisted Rankine cycle for performance enhancement of a biomass-driven power plant; Thermoeconomic and environmental impact assessment. Process Saf. Environ. Prot. 175 (January), 341–354. https://doi. org/10. 1016/j. psep. 2023. 05. 008.
35. [35] Fan, Xiaoyu, et al. , 2023. Thermo-economic analysis of the integrated system of thermal power plant and liquid air energy storage. J. Energy Storage 57 (2022), 106233. https://doi. org/10. 1016/j. est. 2022. 106233.
36. [36] Fritsch, A. , Frantz, C. , Uhlig, R. , 2019. Techno-economic analysis of solar thermal power plants using liquid sodium as heat transfer fluid. Sol. Energy 177 (2018), 155–162. https://doi. org/10. 1016/j. solener. 2018. 10. 005.
37. [37] Lisin, E. , et al. , 2022. Economic analysis of innovative solutions in the use of hydrogen fuel in thermal power plants. Smart Innovation, Systems and Technologies. Springer, Singapore. https://doi. org/10. 1007/978-981-16-8829-4_47.
38. [38] Zhang, H. , et al. , 2023. Simulation and economic analysis of the high-temperature heat storage system of thermal power plants oriented to the smart grid. Front. Energy Res. 10, 1–9. https://doi. org/10. 3389/fenrg. 2022. 1006972.
39. [39] Guidong, J. Lijun, W. ,2013. Economic analysis and operation simulation of low pressure economizer system in 135 MW thermal power plant, Proceedings - 2013 4th International Conference on Digital Manufacturing and Automation, ICDMA 2013, pp. 522–525. doi: 10. 1109/ICDMA. 2013. 123.
40. [40] Çetin, B. , Avcı, H. , 2020. Technical and economic analysis of the conversion on an existing coal-fired thermal power plant to solar-aided hybrid power plant. J. Fac. Eng. Archit. Gazi Univ. 35 (2), 1027–1045. https://doi. org/10. 17341/ gazimmfd. 418417.
41. [41] Oktay, Z. , “Investigation of coal-fired power plants in Turkey and a case study: Can plant”, Applied Thermal Engineering, 29: 550-557 (2009)
42. [42] Palmer, C. A. , Tuncalı, E. , Dennen, K. O. , Coburn, T. C. , Finkelman, R. B. , “Characterization of Turkish coals: a nationwide perspective”, International Journal of Coal Geology, 60 (2-4): 85-115 (2004)
43. [43] Elektrik Üretim A. Ş. , “4x360 MW Afşin Elbistan B Termik Santrali”, EÜAŞ,Ankara, 1-14, (2010)
44. [44] Ege, A. , “Afşin-Elbistan Kömür Santralinin Ekserji ve Termoekonomik Analizi ve Optimizasyonu”, Doktora Tezi, Gazi Üniversitesi Fen Bilimleri Enstitüsü, Ankara, 35-46, 101-127, 153-159 (2012)
45. [45] Park, K. , Shin, D. , Yoon, E. S. , “The cost of energy analysis and energy planning for emerging, fossil fuel powerplants based on the climate change scenarios”, Energy, 36, 3606-3612 (2011)
46. [46] International Energy Agency, Nuclear Energy Agency, Organisation For Economic Co-Operation and Development, “Projected Costs of Generating Electricity”, IEA NEA OECD, Paris, 153, (2010)
47. [47] International Atomic Energy Agency, “Economic Evaluation of Bids for Nuclear Power Plants”, IAEA, Vienna, 32-34, 63-70, (2000)
48. [48] International Energy Agency, Nuclear Energy Agency, Organisation For Economic Co-Operation and Development, “Projected Costs of Generating Electricity”, IEA NEA OECD, Paris, 153, (2005)
49. [49] Eruysal, E. , “ Emtia Piyasalarında Güncel Gelişmeler” EADGM, Ankara, 19, (2012)
50. [50] İnternet : Türkiye İstatistik Kurumu “2005 Kömür Madenciliği Artış Oranları Hesabı” http://tuikapp. tuik. gov. tr/ufedagitimapp/ (2012).
51. [51] İnternet : Türkiye Cumhuriyeti Merkez Bankası “Enflasyon Hesaplayıcısı” http://www3. tcmb. gov. tr/enflasyon/enflasyon_anayeni. php (2012).