Experimental Investigation into the Impact of Natural Gas-Diesel Mixture on Exhaust Emissions and Engine Performance in a Heavy-Duty Diesel Engine with Six Cylinders

Year 2023, Volume: 7 Issue: 4, 360 - 371, 31.12.2023

Volkan Sabri Kül , S. Orhan Akansu

https://doi.org/10.30939/ijastech..1315920

Cited By: 3

Abstract

In this study, experiments were conducted with a mixture of pure diesel and natural gas. In the experiments, a 6-cylinder heavy-duty diesel engine with an engine displacement of 11,670 cc was used and the engine speed was kept constant at 660 rpm. At 660 rpm engine speed, the maximum torque value reached was 386 Nm. The 386 Nm torque value was accepted as 100% and experiments were carried out at torque ratios of 25, 50, 75 and 100%. In all experiments with natural gas mixture, natural gas was delivered to the combustion chamber at a pressure of 1.5 bar and a flow rate of 1.29 g/sec, pre-mixed with air from the intake manifold. The aim of this study is to investigate the combustion characteristics of pure diesel and natural gas mixtures in a heavy-duty diesel engine. According to the test results, the BTE value of natural gas - diesel blended fuel decreased by 157, 89, 53, 53 and 28% at 25, 50, 75, 100 torque values, respectively, compared to pure diesel. It was observed that at low torque values, natural gas - diesel blended fuel was very inefficient, but as the torque value increased, there were improvements in the BTE value of natural gas - diesel blended fuel, although it could not reach the BTE value of pure diesel. In the experiments with pure diesel, it was determined that the fuel consumption was 127, 68, 38, 17% less than the natural gas - diesel blended fuel at torque values of 25, 50, 75, 100%, respectively. The most significant change in exhaust emissions was observed in CO and UHC emissions. At maximum load, CO and UHC emissions were found to be 4.42 and 4.5 g/kWh for pure diesel and 19.9 and 11.9 g/kWh for natural gas blend, respectively.

Keywords

Diesel, Natural Gas, Dual Fuel, Emission, Performance

Thanks

ACKNOWLEDGEMENT The authors acknowledge The Erciyes University Scientific Research Projects Unit for supporting this study with the project number of FBG-2014-5234 and Naturelgaz Sanayi Ve Ticaret A.Ş. for CNG (Compressed Natural Gas) support

References

• [1] Reşitoğlu İA, Altinişik K, & Keskin A. The pollutant emissions from diesel-engine vehicles and exhaust aftertreatment systems. Clean Technologies and Environmental Policy. 2015; 17;1; 15-27. https://doi.org/10.1007/s10098-014-0793-9
• [2] Hoang AT. Waste heat recovery from diesel engines based on Or-ganic Rankine Cycle. Applied energy. 2018; 231; 138-166. https://doi.org/10.1016/j.apenergy.2018.09.022
• [3] Zhou JH, Cheung CS, Leung CW. Combustion, performance and emissions of a diesel engine with H2, CH4 and H2–CH4 ad-dition. International journal of hydrogen energy. 2014; 39;9; 4611-4621. https://doi.org/10.1016/j.ijhydene.2013.12.194
• [4] Kober T, Schiffer HW, Densing M, Panos E. Global energy perspectives to 2060–WEC's World Energy Scenarios 2019. Energy Strategy Reviews. 2020; 31; 100523. https://doi.org/10.1016/j.esr.2020.100523
• [5] Dale S. BP statistical review of world energy. BP Plc: London, UK. 2021; 14-16.
• [6] Huang H, Zhu Z, Chen Y, Chen Y, Lv D, Zhu J, Ouyang T. Experimental and numerical study of multiple injection effects on combustion and emission characteristics of natural gas–diesel dual-fuel engine. Energy Conversion and Management. 2019; 183;84–96. https://doi.org/10.1016/j.enconman.2018.12.110
• [7] Tree DR, Svensson KI. Soot processes in compression ignition engines. Progress in Energy and Combustion Science. 2007; 33;3; 272–309.https://doi.org/10.1016/j.pecs.2006.03.002
• [8] Liu J, Yang F, Wang H, Ouyang M, Hao S. Effects of pilot fuel quantity on the emissions characteristics of a CNG/diesel dual fuel engine with optimized pilot injection timing. Applied Ener-gy. 2013; 110; 201-206. https://doi.org/10.1016/j.apenergy.2013.03.024
• [9] Ulishney CJ, Dumitrescu CE. Effect of gas composition on the performance and emissions of a dual-fuel diesel-natural gas engine at low load conditions. Fuel. 2022; 324; 124531. https://doi.org/10.1016/j.fuel.2022.124531
• [10] Tutak W, Jamrozik A, Grab-Rogaliński K. Effect of natural gas enrichment with hydrogen on combustion process and emission characteristic of a dual fuel diesel engine. Interna-tional Journal of Hydrogen Energy. 2020; 45;15; 9088-9097. https://doi.org/10.1016/j.ijhydene.2020.01.080
• [11] Bhowmik S, Paul A, Panua R. Performance, exhaust emission and combustion of ethanol–diesel–compressed natu-ral gas dual-fuel compression-ignition engine: a trade-off study. Clean Technologies and Environmental Policy. 2022; 1-20. https://doi.org/10.1007/s10098-021-02256-z
• [12] Thangavel V, Subramanian B, Ponnusamy VK. Investi-gations on the effect of H2 and HHO gas induction on brake thermal efficiency of dual-fuel CI engine. Fuel. 2022; 126888. https://doi.org/10.1016/j.fuel.2022.126888
• [13] Ramalingam S, Rajendran S. Assessment of performance, combustion, and emission behavior of novel annona biodiesel-operated diesel engine. In Advances in eco-fuels for a sustain-able environment. 2019; 391-405. https://doi.org/10.1016/B978-0-08-102728-8.00014-0
• [14] Zhou H, Li X, Lee CFF. Investigation on soot emissions from diesel-CNG dual-fuel. International Journal of Hydrogen Energy. 2019; 44;18; 9438–9449. https://doi.org/10.1016/j.ijhydene.2019.02.012
• [15] Meng X, Tian H, Long W, Zhou Y, Bi M, Tian J, Lee CFF. Experimental study of using additive in the pilot fuel on the performance and emission trade-offs in the diesel/CNG (methane emulated) dual-fuel combustion mode. Applied Thermal Engineering. 2019; 157; 113718. https://doi.org/10.1016/j.applthermaleng.2019.113718
• [16] Demirci OK, Çınar C. HCCI-DI bir motorda doğal gaz kullanımının performans ve egzoz emisyonlarına etkisinin incelenmesi. Gazi University Journal of Science Part C: Design and Technology. 2019; 7;2; 317-330. https://doi.org/10.29109/gujsc.521668
• [17] Kül VS, Akansu SO. Experimental Investigation of the impact of boron nanoparticles and CNG on performance and emissions of Heavy-Duty diesel engines. Fuel. 2022; 324; 124470. https://doi.org/10.1016/j.fuel.2022.124470
• [18] Hwang J, Hirner FS, Bae C, Patel C, Gupta T, Agarwal AK. HRTEM evaluation of primary soot particles originated in a small-bore biofuel compression-ignition engine. Applied Thermal Engineering. 2019; 159; 113899. https://doi.org/10.1016/j.applthermaleng.2019.113899
• [19] Pulkrabek WW. Engineering Fundamentals of the Inter-nal Combustion Engines Novi Bios. 2021.
• [20] Mohammad NKJ, Mansor WNW, Abdullah S, Wan C, Othman AAB, Sheikh AA, Jalaludin J. Effects of exhaust emis-sions from diesel engine applications on environment and health: a review. Journal of Sustainability Science and Man-agement. 2022; 17;1; 281-301. http://doi.org/10.46754/jssm.2022.01.019
• [21] Turns SR. An introduction to combustion: con-cepts and applications. Boston; WCB/McGraw-Hill. 2000.
• [22] Albayrak ÇB, Yıldız M, Akansu SO, Kahraman N. Per-formance and emission characteristics of an IC engine under SI, SI-CAI and CAI combustion modes. Energy. 2017; 136; 72-79. https://doi.org/10.1016/j.energy.2016.08.038
• [23] Yıldız M, Çeper BA. Experimental Study on an SI En-gine Mapping Considering Performance, Emissions, and Cyclic Variability. Energy, Environment and Storage. 2021; 01;01; 42-49. https://doi.org/10.52924/BBNP1133
• [24] Mamedov I, Huseynova S, Javadova O, Azimova N, Huseynova R, Gasimova S. Testing of pine oil and glycerol ketal as components of B10 fuel blend. Energy, Environment and Storage. 2010; 11; 11-14. https://doi.org/10.52924/SMQS5726
• [25] Ceviz MA, Öner IV, Kaya F, Karacali T. Analysis of the thermal efficiency and cyclic variations in a SI engine under lean combustion conditions. Journal of Thermal Science and Technology. 2011 31;1; 121-127.
• [26] Martyr AJ, Plint MA. The combustion process and com-bustion analysis. In Engine Testing. 2012; 15; 375-406. https://doi.org/10.1016/B978-0-08-096949-7.00015-7
• [27] Bizon K, Continillo G, Lombardi S, Mancaruso E, Va-glieco BM. ANN-based virtual sensor for on-line prediction of in-cylinder pressure in a diesel engine. In Computer Aided Chemical Engineering. 2014; 33; 763-768 https://doi.org/10.1016/B978-0-444-63456-6.50128-9
• [28] Borat O, Balcı M, Sürmen A. İçten yanmalı motorlar. Teknik Eğitim Vakfı. 1994.
• [29] Wang Z, Zhao Z, Wang D, Tan M, Han Y, Liu Z, Dou H. Impact of pilot diesel ignition mode on combustion and emis-sions characteristics of a diesel/natural gas dual fuel heavy-duty engine. Fuel. 2016; 167; 248-256. https://doi.org/10.1016/j.fuel.2015.11.077
• [30] Uyumaz A, Solmaz H. Rcci Bir Motorda Enjeksiyon Zamanlamasi Ve Lamdanin Yanma Ve Performans Karakteris-tikleri Üzerindeki Etkilerinin Deneysel İncelenmesi. Gazi Uni-versity Journal of Science. 2016; Part C: Design and Technolo-gy, 4;4; 299-308. https://dergipark.org.tr/en/pub/gujsc/issue/45198/565997
• [31] You J, Liu Z, Wang ., Wang D, Xu Y, Du G, Fu X. The exhausted gas recirculation improved brake thermal efficiency and combustion characteristics under different intake throttling conditions of a diesel/natural gas dual fuel engine at low loads. Fuel. 2020; 266; 117035. https://doi.org/10.1016/j.fuel.2020.117035
• [32] Coşkun AD, Kül VS, Akansu SO. Experimental Investi-gation of the Effect of Acetone Additive to Diesel Fuel on En-gine Performance and Exhaust Emissions at Partial Loads. En-ergy, Environment and Storage. 2023; 03;01; 12-18 https://doi.org/10.52924/WQJR9374
• [33] Pedrozo VB, Wang X, Guan W, Zhao H. The effects of natural gas composition on conventional dual-fuel and reactivi-ty-controlled compression ignition combustion in a heavy-duty diesel engine. International Journal of Engine Research. 2021; 23;3; 397–415. https://doi.org/10.1177/1468087420984044
• [34] Felayati FM, Cahyono B, Bakar RA, Birouk M. Perfor-mance and emissions of natural gas/diesel dual-fuel engine at low load conditions: Effect of natural gas split injection strategy. Fuel. 2021; 300; 121012. https://doi.org/10.1016/j.fuel.2021.121012
• [35] Armin M, Gholinia M. Comparative evaluation of energy, performance, and emission characteristics in dual-fuel (CH4/Diesel) heavy-duty engine with RCCI combustion mode. Results in Engineering. 2022; 16; 100766. https://doi.org/10.1016/j.rineng.2022.100766
• [36] Park C, Kim C, Lee S, Lee S, Lee J. Comparative evalua-tion of performance and emissions of CNG engine for heavy-duty vehicles fueled with various caloric natural gases. Energy. 2019; 174; 1–9. https://doi.org/10.1016/j.energy.2019.02.120
• [37] Zhang Z, Lv J, L, W, Long J, Wang S, Tan D, Yin Z. Performance and emission evaluation of a marine diesel engine fueled with natural gas ignited by biodiesel-diesel blended fuel. Energy. 2022; 256; 124662. https://doi.org/10.1016/j.energy.2022.124662
• [38] Liu J, Guo Q, Guo J, Wang F. Optimization of a die-sel/natural gas dual fuel engine under different diesel substitu-tion ratios. Fuel. 2021; 305; 121522. https://doi.org/10.1016/j.fuel.2021.121522
• [39] Zheng F, Zhang H, Yin H, Fu M, Jiang H, Li J, Ding Y. Evaluation of real-world emissions of China V heavy-duty ve-hicles fueled by diesel, CNG and LNG on various road types. Chemosphere. 2022; 303; 135137. https://doi.org/10.1016/j.chemosphere.2022.135137
• [40] Appaswamy ST, Kumar A, Kumar S, Reddy VHV, Nashthrasan D, Buranpur SS, Mudhol LV. Analysis of (CNG + Diesel) in double fuel mode in a diesel engine for emissions and performance characteristics. AIP Conference Proceedings. 2023. https://doi.org/10.1063/5.0154919
• [41] Shim E, Park H, Bae C. Comparisons of advanced com-bustion technologies (HCCI, PCCI, and dual-fuel PCCI) on en-gine performance and emission characteristics in a heavy-duty diesel engine. Fuel. 2020; 262; 116436. https://doi.org/10.1016/j.fuel.2019.116436
• [42] Deng J, Wang X, Wei Z, Wang L, Wang C, Chen Z. A review of NOx and SOx emission reduction technologies for marine diesel engines and the potential evaluation of liquefied natural gas fuelled vessels. Science of The Total Environment. 2021; 766; 144319. https://doi.org/10.1016/j.scitotenv.2020.144319
• [43] Liu J, Ulishney CJ, Dumitrescu CE. Experimental inves-tigation of a heavy-duty natural gas engine performance oper-ated at stoichiometric and lean operations. Energy Conversion and Management. 2021; 243; 114401. https://doi.org/10.1016/j.enconman.2021.114401
• [44] Ulishney CJ, Dumitrescu CE. Effect of gas composition on the performance and emissions of a dual-fuel diesel-natural gas engine at low load conditions. Fuel. 2022; 324; 124531. https://doi.org/10.1016/j.fuel.2022.124531
• [45] Yousefi A, Guo H, Birouk M. Split diesel injection ef-fect on knocking of natural gas/diesel dual-fuel engine at high load conditions. Applied Energy. 2020; 279; 115828. https://doi.org/10.1016/j.apenergy.2020.115828
• [46] Jamrozik A, Tutak W, Grab-Rogaliński K. An Experi-mental Study on the Performance and Emission of the die-sel/CNG Dual-Fuel Combustion Mode in a Stationary CI Engine. Energies. 2019; 12;20; 38-57. https://doi.org/10.3390/en12203857