Effect of Heat Treatment on Aflatoxin Contents of Tomatoes Samples in Ilorin, Kwara State, Nigeria

Year 2020, Volume: 3 Issue: 1, 18 - 26, 15.04.2020

Wakili Aborisade , Abdullahi Ajao , Jimoh Fausat

https://doi.org/10.38001/ijlsb.664750

Abstract

Fungi contamination of agricultural products had been one of the major concerns to human due to their possibility of causing spoilage and the potential of producing potent toxins that could constitute health problems. Therefore, this study evaluates the effect of heat treatment on aflatoxin contents of tomatoes samples in some selected market in Ilorin, Kwara State, Nigeria. The spoilt and fresh tomatoes samples were randomly purchased from nine vendors for analysis. Fungi were isolated on Sabroud dextrose agar and identified using colonial and morphological characteristics. The levels of aflatoxin in the samples were determined using ELISA techniques and effects of heat treatments on aflatoxin levels of the samples were determined before and after 5, 15, 25 and 35 minutes of heat treatments at 100 oC. The results revealed the presence of fungi contaminants in all the analysed samples irrespective of their quality status. Furthermore, the aflatoxins contaminants were not detected in all the evaluated fresh samples; whereas the presence of aflatoxin in the spoilt samples was observed. The average aflatoxin contents of spoilt samples were 7.83, 8.17 and 8.62 µg/kg respectively, with no significant differences among the values. The effect heat treatments on the aflatoxin contaminated samples were observed to be time dependent. About 7.5 % non-significant reductions (p > 0.05) in aflatoxin contents of the samples were observed after 5 min of heat treatment. While, significant reduction of about 45.0 %, 53.1 % and 71.5 % were observed after 15, 25 and 35 minutes of heat treatments respectively. This is an indication that proper cooking at 100 oC, over a period of time could significantly reduce aflatoxin level in some food products that are usually subjected to cooking prior to consumption.

Keywords

Aflatoxins, ELISA, Fungi, Heat, Tomatoes

Supporting Institution

Kwara State University, Malete

References

• Udoh, I. P., C. I. Eleazar, B. O. Ogeneh, and M. E. Ohanu, Studies on fungi responsible for the spoilage / deterioration of some edible fruits and vegetables. Advances in Microbiology, 2015. 5: p. 285-290.
• Drusch, S. and W. Ragab, Mycotoxins in fruits, fruit juices and dried fruits. Journal of Food Protection, 2003. 66(8): p. 1514-1527. Makun, H. A., et al., Fungal and aflatoxin contamination of some human food commodities in Nigeria. African Journal of Food Science, 2010. 4(4): p. 127-135. Onuorah, S. and M. U. Orji, Fungi associated with the spoilage of post-harvest tomato fruits sold in major markets in Awka, Nigeria. Universal Journal of Microbiology Research, 2015. 3(2): p. 11-16.
• Sadiq, S. I. and T. I. Aliyu, Comparative nutritional composition of raw and canned tomatoes Solanum lycopersicum (Lycopersicon esculentum) Dutse Market Jigawa State, Nigeria. Dutse Journal of Pure and Applied Sciences, 2018. 4(2): p. 424-433.
• Danaan, V. V., Analysing poverty in Nigeria through theoretical lenses. Journal of Sustainable Development, 2018. 11(1): p. 20 – 31.
• Khoshpey, B., D. D. Farhud, and F. Zaini, Aflatoxins in Iran: nature, hazards and carcinogenicity. Iranian Journal of Public Health, 2011. 40(4): p. 1-30.
• Kumar, P., et al., Aflatoxins: A global concern for food safety, human health and their management. Frontier in Microbiology, 2016. 7: p. 1-10.
• Suleiman, M. S., et al., Fungi and Aflatoxin Occurrence in Fresh and Dried Vegetables Marketed in Minna, Niger State, Nigeria. Journal of Biochemistry and Physiology, 2017. 5(1): p. 1 – 4.
• Zhang, W., et al., Screening a strain of Aspregillus niger and optimization of fermentation conditions for degradation of aflatoxin B1. Toxins, 2014. 6: p. 3158 -3172.
• Ogbeibu, A. E. Biostatistics A Practical Approach to Research and Data Handling. Mindex Publishing Company Limited, Edo State, Nigeria, 2005. pp. 265.
• Kaczmarek, M., S. V. Avery, and I. Singleton, Microbes associated with fresh produce: sources, types and methods to reduce spoilage and contamination. Advances in Applied Microbiology 2019. 107: p. 29-82.
• Adeyeye, S. A. O., Fungal mycotoxins in foods: A review. Journal of Cogent Food and Agriculture, 2016. 2: p. 1-11.
• Williams, O. I., et al., Occurrence of Aflatoxin in some food commodities commonly consumed in Nigeria. Journal of Food Research, 2015. 4(5): p. 81-88.
• Diedhiou, P. M., et al., Effect of different cooking methods on aflatoxin fate in peanut products. African Journal of Food Science and Technology, 2012. 3(2): p. 53-58.