Single-Source MPPT-Controlled 5-Level Inverter for Photovoltaic Applications

Öz

This study proposes a five-level multilevel inverter (MLI) topology for photovoltaic (PV) applications, employing a single DC source and fed through a Maximum Power Point Tracking (MPPT)-controlled boost front-end stage. The proposed topology achieves a two-fold voltage gain without requiring an additional DC source, offering a favorable performance-to-cost trade-off with low hardware complexity. The performance of the topology was evaluated in the MATLAB/Simulink environment under Nearest Level Control (NLC) and Sinusoidal Pulse Width Modulation (SPWM) methods; switching and conduction losses were calculated using thermal models in PLECS software. Under a 100 Ω + 50 mH load condition, the total harmonic distortion (THD) of 8.20% obtained with the NLC method was reduced to 6.11%, 3.79%, and 3.42%, respectively, with the SPWM method as the carrier frequency was increased from 1.25 kHz to 5 kHz. The topology exhibited stable and fast dynamic response over output frequency ranges of 25-200 Hz and modulation index ranges of 0.3-1.0, achieving a peak efficiency of 97.35% across the output power range of 0–1000 W. A quantitative comparison with similar five- and seven-level topologies in the literature demonstrates that the proposed structure stands out with a lower cost function value and reduced hardware complexity. The obtained results show that the proposed single-source, MPPT-controlled topology strikes a practical balance between low switching loss and low harmonic distortion, constituting a highly efficient and scalable solution for PV systems.

Anahtar Kelimeler

• Multilevel inverter
• MPPT
• NLC
• SPWM
• THD
• Photovoltaic systems

Fotovoltaik Uygulamalar İçin Tek Kaynak MPPT Kontrollü 5 Seviyeli Evirici

Öz

Bu çalışmada, fotovoltaik (PV) uygulamalar için tek bir DC kaynağı kullanan, Maksimum Güç Noktası Takibi (MPPT) kontrollü bir boost ön kademesiyle beslenen beş seviyeli birçok seviyeli evirici (ÇSE) topolojisi önerilmektedir. Önerilen topoloji, ek bir DC kaynağa gerek duymadan iki kat gerilim kazancı sağlamakta ve düşük donanım karmaşıklığıyla yüksek bir performans-maliyet dengesi sunmaktadır. Topolojinin performansı, Nearest Level Control (NLC) ve Sinüzoidal Darbe Genişlik Modülasyonu (SPWM) yöntemleri altında MATLAB/Simulink ortamında değerlendirilmiş; anahtarlama ve iletim kayıpları PLECS yazılımı ile termal modeller kullanılarak hesaplanmıştır. 100 Ω + 50 mH yük koşulunda NLC yöntemiyle %8,20 olan toplam harmonik bozulma (THD), SPWM yönteminde taşıyıcı frekansının 1,25 kHz'den 5 kHz'e yükseltilmesiyle sırasıyla %6,11, %3,79 ve %3,42 değerlerine düşürülmüştür. Topoloji, 25-200 Hz çıkış frekansı ve 0,3-1,0 modülasyon indeksi aralıklarında kararlı ve hızlı bir dinamik yanıt sergilemiş, 0-1000 W çıkış güç aralığında %97,35 ile en yüksek verime ulaşmıştır. Literatürdeki benzer beş ve yedi seviyeli topolojilerle yapılan nicel karşılaştırma, önerilen yapının daha düşük maliyet fonksiyonu değeri ve daha az donanım karmaşıklığıyla öne çıktığını ortaya koymaktadır. Elde edilen sonuçlar, önerilen tek kaynaklı ve MPPT kontrollü topolojinin, düşük anahtarlama kaybı ile düşük harmonik bozulma arasında pratik bir denge sağlayarak yüksek verimli ve PV sistemler için ölçeklenebilir bir çözüm oluşturduğunu göstermektedir.

Anahtar Kelimeler

• Çok seviyeli evirici
• MPPT
• NLC
• SPWM
• THD
• Fotovoltaik sistemler

Etik Beyan

Bu araştırmada hayvanlar ve insanlar üzerinde herhangi bir çalışma yapılmadığı için etik kurul onayı alınmamıştır.

Kaynakça

1. Choudhary, A., & Kumar Mandal, R. (2025). A five-level boosting inverter for grid-tied photovoltaic application. International Journal of Circuit Theory and Applications, 53(8), 4475–4487. https://doi.org/10.1002/cta.4375
2. Devulal, B., Siva, M., & Kumar, D. R. (2025). Design of a novel three phase hybrid converter for microgrids application using renewable energy sources. International Journal of Electrical and Computer Engineering (IJECE), 15(2), 1473–1486. https://doi.org/10.11591/ijece.v15i2.pp1473-1486
3. Gürçam, K. (2026). Enhanced symmetric five-level multi-stage inverter for solar energy systems. IEEE Access, 14, 120511–120522. https://doi.org/10.1109/ACCESS.2026.3718094
4. Hataş, H. (2025). Design and performance analysis of a single-source cascaded H-bridge multilevel inverter with switched rectifier. Engineering Research Express, 7(1), Article 015092. https://doi.org/10.1088/2631-8695/adbab2
5. Islam, S., Daula Siddique, M., Hussan, M. R., & Iqbal, A. (2023). Reduced voltage stress and spikes in source current of 7-level switched-capacitor based multilevel inverter. IEEE Access, 11, 74722–74735. https://doi.org/10.1109/ACCESS.2023.3297496
6. İşcan, S., Kaplan, O., & Lokman, G. (2021). Power loss and voltage stability optimization with meta-heuristic algorithms in power system. Pamukkale Üniversitesi Mühendislik Bilimleri Dergisi, 27(2), 209–216. https://doi.org/10.5505/pajes.2020.82582
7. Jena, K., Gupta, K. K., Kumar, D., & RanjanKabat, S. (2024). Single-stage single-phase 5-level switched-capacitor multilevel inverter. Iranian Journal of Science and Technology - Transactions of Electrical Engineering, 48(1), 265–276. https://doi.org/10.1007/s40998-023-00660-3
8. Karakılıç, M. (2025). A novel Hexagonal Switched Capacitor Unit (HSCU) design with seven-level multilevel inverter topology. International Journal of Circuit Theory and Applications, 53(11), 6820–6836. https://doi.org/10.1002/cta.4469

9. Karakılıç, M., & Almalı, M. N. (2024). Design of hybrid switched diode multilevel inverter using single DC source. Journal of Electrical Engineering & Technology, 19(7), 4169–4180. https://doi.org/10.1007/s42835-024-01832-9
10. Karakılıç, M., & Hataş, H. (2025). Yenilenebilir enerji sistemleri için düşük maliyetli ve yüksek verimli yeni bir 15 seviyeli hibrit ÇSI topolojisi. Gazi Üniversitesi Fen Bilimleri Dergisi Part C: Tasarım ve Teknoloji, 13(2), 522–536. https://doi.org/10.29109/gujsc.1631487
11. Karakılıç, M., Hataş, H., & Nuri Almalı, M. (2023). Design of a 21-level multilevel inverter with minimum number of devices count. International Journal of Circuit Theory and Applications, 51(12), 5705–5723. https://doi.org/10.1002/cta.3730
12. Khasim, S. R., Dhanamjayulu, C., Padmanaban, S., Holm-Nielsen, J. B., & Mitolo, M. (2021). A novel asymmetrical 21-level inverter for solar PV energy system with reduced switch count. IEEE Access, 9, 11743–11756. https://doi.org/10.1109/ACCESS.2021.3051039
13. Kumar, D., Nema, R. K., & Gupta, S. (2021). Development of fault-tolerant reduced device version with switched-capacitor based multilevel inverter topologies. International Transactions on Electrical Energy Systems, 31(7), Article e12893. https://doi.org/10.1002/2050-7038.12893
14. Kuncham, S. K., Annamalai, K., & Subrahmanyam, N. (2020). A two-stage T-type hybrid five-level transformerless inverter for PV applications. IEEE Transactions on Power Electronics, 35(9), 9512–9523. https://doi.org/10.1109/TPEL.2020.2973340
15. Lin, W., Zeng, J., Fu, B., Yan, Z., & Liu, J. (2024). Switched-capacitor based seven-level boost inverter with a reduced number of devices. CSEE Journal of Power and Energy Systems, 10(1), 381–391. https://doi.org/10.17775/CSEEJPES.2020.02620
16. Liu, J., Wu, J., & Zeng, J. (2018). Symmetric/asymmetric hybrid multilevel inverters integrating switched-capacitor techniques. IEEE Journal of Emerging and Selected Topics in Power Electronics, 6(3), 1616–1626. https://doi.org/10.1109/JESTPE.2018.2848675
17. Maheswari, K. T., Bharanikumar, R., Arjun, V., Amrish, R., & Bhuvanesh, M. (2021). A comprehensive review on cascaded H-bridge multilevel inverter for medium voltage high power applications. Materials Today: Proceedings, 45, 2666–2670. https://doi.org/10.1016/j.matpr.2020.11.519
18. Memis, M., & Karakilic, M. (2025). 7-level soft charging switched capacitor multilevel inverter. IEEE Access, 13, 51020–51032. https://doi.org/10.1109/ACCESS.2025.3560576
19. Meraj, S. T., Yahaya, N. Z., Hasan, K., & Masaoud, A. (2021). A hybrid T-type (HT-type) multilevel inverter with reduced components. Ain Shams Engineering Journal, 12(2), 1959–1971. https://doi.org/10.1016/j.asej.2020.12.010
20. Mondal, S., Biswas, S. P., Islam, M. R., & Muyeen, S. M. (2023). A five-level switched-capacitor based transformerless inverter with boosting capability for grid-tied PV applications. IEEE Access, 11, 12426–12443. https://doi.org/10.1109/ACCESS.2023.3241927
21. Nabae, A., Takahashi, I., & Akagi, H. (1981). A new neutral-point-clamped PWM inverter. IEEE Transactions on Industry Applications, IA-17(5), 518–523. https://doi.org/10.1109/TIA.1981.4503992
22. Papamanolis, P., Neumayr, D., & Kolar, J. W. (2017). Behavior of the flying capacitor converter under critical operating conditions. In 2017 IEEE International Symposium on Industrial Electronics (ISIE) (pp. 411–418). IEEE. https://doi.org/10.1109/ISIE.2017.8001319
23. Pardhu, B. S. S. G., & Kota, V. R. (2024). A novel HRMO-AOA approach for a grid integrated wind-solar PV system with a 5-level NPC inverter. Results in Engineering, 23, Article 102582. https://doi.org/10.1016/j.rineng.2024.102582
24. Sarkar, I., & Fernandes, B. G. (2023). A hybrid symmetric cascaded H-bridge multilevel converter topology. IEEE Journal of Emerging and Selected Topics in Power Electronics, 11(4), 4210–4220. https://doi.org/10.1109/JESTPE.2021.3104222
25. Sarwer, Z., Anwar, M. N., & Sarwar, A. (2022). Design and investigation of a triple boost multilevel inverter with self-balanced switched capacitors and reduced voltage stress. International Journal of Circuit Theory and Applications, 50(5), 1652–1666. https://doi.org/10.1002/cta.3216
26. Sirsa, A., Mittal, A., & Ojha, A. (2024). A new symmetrical five level multilevel inverter topology for standalone solar PV based system. Iranian Journal of Science and Technology - Transactions of Electrical Engineering, 48(3), 1105–1117. https://doi.org/10.1007/s40998-024-00732-y
27. Surapu, P. R., Sandeep, N., & Verma, A. K. (2024). A nine-level midpoint-clamped inverter with full DC-bus utilization and suppressed charging current for PV application. IEEE Journal of Emerging and Selected Topics in Power Electronics, 12(3), 2910–2920. https://doi.org/10.1109/JESTPE.2024.3375391
28. Usha, K., Ranesh, S., & Swathi, G. (2025). Nine-level boost MLI for small scale PV applications. In 2025 International Conference on Recent Advances in Electrical, Electronics, Ubiquitous Communication, and Computational Intelligence (RAEEUCCI) (pp. 1–6). IEEE. https://doi.org/10.1109/RAEEUCCI63961.2025.11048239
29. Yadav, A. K., Gopakumar, K., Krishna Raj, R., Umanand, L., Bhattacharya, S., & Jarzyna, W. (2019). A hybrid 7-level inverter using low-voltage devices and operation with single DC-link. IEEE Transactions on Power Electronics, 34(10), 9844–9853. https://doi.org/10.1109/TPEL.2018.2890371
30. Zaid, M., Moonis, A. R., Sarwar, A., Iqbal, A., & Tayyab, M. (2024). Seven-level single-source switched capacitor inverter with triple boosting capability and high reliability. International Journal of Circuit Theory and Applications, 52(8), 3844–3869. https://doi.org/10.1002/cta.3946
31. Zuhur, S. (2026). A frequency- and power-dependent semi-analytical model for wideband RF energy harvesting rectifiers. Micromachines, 17(1), Article 30. https://doi.org/10.3390/mi17010030