INVESTIGATIONS ON THE PERFORMANCE AND EXHAUST EMISSIONS OF A DIESEL ENGINE USING SUNFLOWER METHYL ESTER OIL AS FUEL

Öz

In this experimental study, the effects of the usage of sunflower oils, as alternative fuels, performance and exhaust emissions in a single and naturally aspirated diesel engine were investigated. The biodiesel was produced by a transesterification technique. Methyl esters obtained from sunflower oils were tested as diesel fuels, blended with  25 %, 50 %, 75 % of a No. 2D diesel fuel which was also used pure. In order to determine emission and performance characteristics, the engine was tested with full load-varied speed. Engine performance and emission characteristics of different fuels in a diesel engine were investigated and compared with the base diesel fuel. Observations showed that smoke density and CO emissions decreased with increasing oxygenate content in the fuels but NO_x emissions slight increased. Biodiesels presented a slight increase in specific fuel consumption, but engine power decreased. The temperature of the exhaust gases is similar to No.2D fuel. 

Anahtar Kelimeler

• Biodiesel,Sunflower oil,Diesel engine,Exhaust emissions

YAKIT OLARAK AYÇİÇEK METİL ESTER KULLANILAN BİR DİZEL MOTORUNDA PERFORMANS VE EMİSYONUN İNCELENMESİ

Öz

Bu deneysel çalışmada,  tek silindirli, doğal emişli bir dizel motorda alternatif yakıt olarak ayçiçek metil esterinin performans ve emisyonlar üzerindeki etkileri araştırılmıştır. Biyodizel üretim yöntemi olarak transesterfikasyon yöntemi kullanılmıştır. Ayçiçek yağından elde edilen metil ester, No. 2D dizel yakıtı ile  % 25, % 50, % 75 oranında karıştırılarak ve saf olarak test edilmiştir. Motorun performans ve emisyon karakteristiklerini belirlemek için testler, tam yük değişken devir şartları altında yapılmıştır. Dizel motoru üzerinde kullanılan yakıtların performans ve emisyon karakteristikleri dizel yakıtı esas alınarak karşılaştırmalı olarak araştırılmıştır. Deney sonuçları biyodizel yakıtının içerisindeki oksijen varlığı ile is ve CO emisyonlarının azaldığı, ancak NO_x’ in biraz arttığını göstermektedir. Biyodizelin özgül yakıt tüketiminde bir miktar artış, motor gücünde ise azalma olmuştur. Egzoz gaz sıcaklığının No.2D dizel yakıtı ile benzer eğilim gösterdiği tespit edilmiştir. 

Anahtar Kelimeler

• Biyodizel,Ayçiçek yağı,Dizel motor,Egzoz emisyonu

Kaynakça

1. [1] Demirbaş, A., doi:10.1016/j.enpol.2007.04.003, “Importance of biodiesel as transportation fuel”, Energy Policy, (2007).
2. [2] Barnwal, B.K. and Sharma, M.P., “Prospects of biodiesel production from vegetable oils in India”, Renewable & Sustainable Energy Reviews, 9: 364 (2004).
3. [3] Yücesu, H.S., Altın, R. ve Çetinkaya, S., “Dizel motorlarında alternatif yakıt olarak bitkisel yağ kullanımının deneysel incelenmesi”, Journal Environment Science, 25: 40 (2001).
4. [4] İçingür, Y. ve Eray, E.M., “Değişik yakıt harmanlarının dizel motorlarında kullanılabilirliğinin deneysel olarak incelenmesi”, Gazi Üniversitesi Fen Bilimleri Dergisi, 16: 589-99 (2003).
5. [5] Lapuerta M., Armas O., Ballesteros R. and Fernandez J., “Diesel emissions from biodiesel derived from spanish potential vegetable oils”, Fuel, 84: 773-80 (2004).
6. [6] Bo, Z., Weibiao, F. and Jingsong A., “Study of fuel consumption when introducing DME or ethanol into diesel engine”, Fuel, 85: 778-82 (2005).
7. [7] Duran, A., Monteaguda, J.M. and Hernandez, J.J., “Scrubbing effect on diesel particulate matter from transesterified waste oils blends”, Fuel, 85: 923-8 (2006).
8. [8] Pang, X., Shi, X., Mu, Y., He., H., Shuai, S., Chen, H. and Li, R., “Characteristics of carbonly compounds emissions from a diesel-engine using biodiesel–ethanol-diesel as fuel, Atmospheric Environment, 40: 7057 (2006).

9. [9] Kalligeros S., Zannikos F., Stournas S., Lois E., Anastopoulos G., Teas Ch., et al., “An investigation of using biodiesel marine diesel blends on the performance of a stationary diesel engine”, Biomass Bioenergy, 24: 141-9 (2003).
10. [10] Tashtoush, G.M., Al-Widyan, M.I. and Albatayneh, A.M., “Factorial analysis of diesel engine performance using different types of biofuels”, Journal of Environment Management, 84: 401-11 (2006).
11. [11] Lin, C.Y. and Lin, H.A., “Diesel engine performance and emission characteristics of biodiesel produced by the peroxidation process”, Fuel, 85: 304 (2006).
12. [12] Heywood J.B., “Internal Combustion Engine Fundamentals”, McGraw-Hill, New York, 526 (1988).
13. [13] Altın, R., Bitkisel Yağların Dizel Motorlarında Yakıt Olarak Kullanılmasının Deneysel Olarak İncelenmesi, Doktora Tezi, Gazi Üniv. Fen Bilm. Enst., 56 (1998).
14. [14] Yamane, K., Ueta, A.and Shimamoto, Y., “Influence of physical and chemical properties of biodiesel fuels on injection, combustion and exhaust mission characteristics in a direct injection compression ignition engine”, International Journal of Engine Research 2: 249-61 (2001).
15. [15] Agarwal, A.K., “Biofuels (alchols and biodiesel) applications as fuels for internal combustion engines”, Progress in Energy and Combustion Science, 33: 233-71 (2007).
16. [16] Borat, O. Balcı, M., ve Sürmen, A., “İçten Yanmalı Motorlar”, Teknik Eğitim Vakfı Yayınları, 260.
17. [17] Lin C.Y. and Lin H.A., “Diesel engine performance and emission characteristics of biodiesel produced by peroxidation process”, Fuel, 85: 298-305 (2006).
18. [18] Hazar, H., ve Öner, C., “The Effects of thermal barrier coating on the engine performance”, 8th International Combustion Symposium, Ankara, 125-6 (2004).
19. [19] Ban-Weiss, G.A., Chen, J.Y., Buchholz, B.A. and Dibble, R.W., “A numerical investigation into the anomalous slight NOx increase when burning biodiesel; a new (old) theory”, Fuel Processing Technology, 88: 659-67 (2007).
20. [20] Nabi, Md.N., Akhter Md.S. and Shahadat, Md.Z., “Improvement of engine emissions with conventional diesel fuel and diesel-biodiesel blends”, Bioresource Technology, 97: 372-8 (2006).
21. [21] Fernando, S., Karra, P., Hernandez, R.and Jha, S.K., “Effect of incompletely converted soybean oil on biodiesel quality”, Energy, 32: 844-51 (2007).
22. [22] Pereira, R.G., Oliveir, C.D., Oliveir, J.L., Oliveir, P.C., Oliveir, C.E.F. and Piamba, OE., “Exhaust emissions and electric energy generation in a stationary engine using blends of diesel and soybean biodiesel”, Renewable Energy, 32: 2453-60 (2007).
23. [23] Shi, X., Pang, X., Mu, Y., He, H., Shuai, S., Wang, J., Chen, H. and Li, R., “Emission reduction potential of using ethanol-biodiesel-diesel fuel blend on heavy-duty diesel engine”, Atmospheric Environment, 40: 2567-74 (2005).
24. [24] Mc Cormick, R.L., Williams, A., Ireland, J., Brimhall, M.and Hayes, R.R., “Effects of biodiesel blends on vehicle emissions”, NREL Milestone Report, MP-540-40554 (2006).
25. [25] Shi, X., Yu, Y., He, H., Shuai, S., Wang, J.and Li, R., “Emission characteristics using methyl soyate-ethanol-diesel fuel blends on a diesel engine”, Fuel, 84: 1543-9 (2005).
26. [26] Raheman, H., Ghadge, S.V., doi: 10.1016/J. fuel.2007.02.019., “Performance of compression ignition engine with mahua ( Madhuca indica) biodiesel”, Fuel, (2007).
27. [27] Karamangil, İ.M., “Buji ateşlemeli motorlarda hidrokarbon emisyon kaynakları”, Mühendis ve Makine, 523 (2003).