The effects of walnut biodiesel- eurodiesel fuel mixtures on the performance and emissions of a diesel engine with common rail fuel system and their combustion characteristics

Yıl 2020, Cilt: 9 Sayı: 4, 205 - 213, 31.12.2020

Hasan Aydoğan , Abdullah Özçelik , Mustafa Acaroğlu

https://doi.org/10.18245/ijaet.782308

Öz

This study is intended to investigate the effects of biodiesel and eurodiesel mixtures, obtained from walnut oil by transesterification method, on engine performance in a four-stroke, four-cylinder, water-cooled with common rail fuel system. 7% biodiesel - 93% eurodiesel (B7), 10% biodiesel - 90% eurodiesel (B10) mixtures were prepared with the fuels obtained from the walnut oil by transesterification method. Later, B7, B10 and eurodiesel (B0) were used as a fuel in diesel engine. In the tests, the engine compression rates of the eurodiesel fuel and biodiesel mixtures were close to each other in all engine rpms. Looking at the average values in the results obtained, it is seen that the highest engine torque value is measured in the range of 2000 - 2500 rpm. Again, in eurodiesel use, the highest engine torque values were measured as 185 Nm. When B7 and B10 fuels were used at the same engine rpm, the engine torque was measured as 165 Nm. As the engine speed increased, it was observed that B7 fuel consumption values were the lowest and the eurodiesel values were the highest. In case of using biodiesel mixtures, it was observed that fuel consumption increased slightly checked to eurodiesel fuel.
When the exhaust emission values were examined, it was seen that the CO emission value was 28% lower than Eurodiesel in B10 fuel, the highest value in CO2 emission was in B10 fuel, HC emission was in Eurodiesel fuel with an increase rate of more than 50% and the highest NOx value was in B10 fuel.
In all cycles, the highest cylinder pressure values were obtained in eurodiesel fuel mixture. Maximum in-cylinder pressure value was obtained as 72 bar in Eurodiesel fuel at 2500 rpm. In the same cycle, 71 and 68 bar in-cylinder pressure values were obtained for B10 and B7 fuels. At 4000 rpm, in-cylinder pressure values were obtained as 80, 77 and 75 bar, respectively, for diesel fuel, B10 and B7 fuel mixtures.

Anahtar Kelimeler

Biodiesel, walnut oil, eurodiesel, common rail, emissions

Kaynakça

• Ambat I., Srivastava V., Sillanpää M. Recent advancement in biodiesel production methodologies using various feedstock: A review. Renewable and Sustainable Energy Reviews, 90, 356-369, 2018.
• Çelebi K., Uludamar E., Özcanlı M. Evaluation of fuel consumption and vibration characteristic of a compression ignition engine fuelled with high viscosity biodiesel and hydrogen addition. International Journal of Hydrogen Energy, 42(36), 23379-88, 2017
• Singh D., Sharma D., Soni S.L., Sharma S., Sharma P.K., Jhalani A. A review on feedstocks, production processes, and yield for different generations of biodiesel. Fuel, 262, 11553-64, 2020
• Daud N.M., Sheikh Abdullah S.R., Abu Hasan H., Yaakob Z. Production of biodiesel and its wastewater treatment technologies: A review. Process Safety and Environmental Protection, 94, 487-508, 2015.
• Demirbas A. Relationships derived from physical properties of vegetable oil and biodiesel fuels. Fuel, 87(8-9), 1743-1748, 2008
• Heidari-Maleni A., Mesri Gundoshmian T., Jahanbakhshi A., Ghobadian B. Performance improvement and exhaust emissions reduction in diesel engine through the use of graphene quantum dot (GQD) nanoparticles and ethanol-biodiesel blends. Fuel, 267, 117116-24, 2020.
• Huang Y., Li Y., Han X., Zhang J., Luo K., Yang S., et al. Investigation on fuel properties and engine performance of the extraction phase liquid of bio-oil/biodiesel blends. Renewable Energy, 47, 1990-2002, 2020.
• Kan X., Wei L., Li X., Li H., Zhou D., Yang W., et al. Effects of the three dual-fuel strategies on performance and emissions of a biodiesel engine. Applied Energy. 262, 114542, 2020.
• Miyamoto M., Takeuchi K. Climate agreement and technology diffusion: Impact of the Kyoto Protocol on international patent applications for renewable energy technologies. Energy Policy, 129, 1331-1338, 2019.
• Khounani Z., Hosseinzadeh-Bandbafha H., Nizami A.S., Sulaiman A., Goli S.A.H., Tavassoli-Kafrani E., et al. Unlocking the potential of walnut husk extract in the production of waste cooking oil-based biodiesel. Renewable and Sustainable Energy Reviews, 119, 109588, 2020.
• Knothe G., Razon L.F. Biodiesel fuels. Progress in Energy and Combustion Science, 58,36-59, 2017.
• Mairizal A.Q., Awad S., Priadi C.R., Hartono D.M., Moersidik S.S., Tazerout M., et al. Experimental study on the effects of feedstock on the properties of biodiesel using multiple linear regressions. Renewable Energy, 145, 375-381, 2020.
• Mirhashemi F.S., Sadrnia H. NOx emissions of compression ignition engines fueled with various biodiesel blends: A review. Journal of the Energy Institute, 93(1), 129-51, 2020.
• Moser B.R. Preparation of fatty acid methyl esters from hazelnut, high-oleic peanut and walnut oils and evaluation as biodiesel. Fuel, 92(1), 231-238, 2012.
• Gürbüz H. Analysis of the effects of multiple injection strategies with hydrogen on engine performance and emissions in diesel engine. International Journal of Hydrogen Energy, 45 (51),27969-27978, 2020.
• Rakopoulos D.C. Heat release analysis of combustion in heavy-duty turbocharged diesel engine operating on blends of diesel fuel with cottonseed or sunflower oils and their bio-diesel. Fuel, 96, 524-34, 2012.
• Roy M.M., Wang W., Bujold J. Biodiesel production and comparison of emissions of a DI diesel engine fueled by biodiesel–diesel and canola oil–diesel blends at high idling operations. Applied Energy, 106, 198-208, 2013.
• Ketenci C.K., Bayramoglu Z. Türkiye’de Ceviz Üretiminin Rekabet Analizi. Türk Tarım ve Doğa Bilimleri Dergisi, 5(3), 339-47, 2018.
• Ercisli S., Sayinci B,. Kara M., Yildiz C., Ozturk I. Determination of size and shape features of walnut (Juglans regia L.) cultivars using image processing. Scientia Horticulturae, 133, 47-55, 2012.
• Gecgel U., Gumus T., Tasan M., Daglioglu O., Arici M. Determination of fatty acid composition of γ-irradiated hazelnuts, walnuts, almonds, and pistachios. Radiation Physics and Chemistry, 80(4), 578-81, 2011.
• Piloto-Rodríguez R., Díaz Y., Melo-Espinosa E.A., Sánchez-Borroto Y., Goyos L., Canoira L., et al. Conversion of fatty acid distillates into biodiesel: engine performance and environmental effects. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 42(4), 387-98, 2020.
• Nautiyal P., Subramanian K.A., Dastidar M.G., Kumar A. Experimental assessment of performance, combustion and emissions of a compression ignition engine fuelled with Spirulina platensis biodiesel. Energy, 193, 116861, 2020
• Kahraman A., Ciniviz M., Örs İ., Oğuz H. The Effect on Performance and Exhaust Emissions of Adding Cotton Oil Methyl Ester to Diesel Fuel. International Journal of Automotive Engineering and Technologies, 5(4), 148-54, 2016.
• Saravanan A., Murugan M., Sreenivasa Reddy M., Parida S. Performance and emission characteristics of variable compression ratio CI engine fueled with dual biodiesel blends of Rapeseed and Mahua. Fuel, 263, 116751, 2020
• Singh M, Sandhu S.S. Performance, emission and combustion characteristics of multi-cylinder CRDI engine fueled with argemone biodiesel/diesel blends. Fuel, 265, 117024, 2020.
• Ogunkunle O., Ahmed N.A. A review of global current scenario of biodiesel adoption and combustion in vehicular diesel engines. Energy Reports, 5, 1560-1579, 2019.
• Shahid E.M., Jamal Y. Production of biodiesel: A technical review. Renewable and Sustainable Energy Reviews, 15(9), 4732-4745, 2011.
• Gozmen Şanli B., Uludamar E., Özcanli M. Evaluation of energetic-exergetic and sustainability parameters of biodiesel fuels produced from palm oil and opium poppy oil as alternative fuels in diesel engines. Fuel, 258, 116116, 2019.
• Çelebi K., Uludamar E., Tosun E., Yıldızhan Ş., Aydın K., Özcanlı M. Experimental and artificial neural network approach of noise and vibration characteristic of an unmodified diesel engine fuelled with conventional diesel, and biodiesel blends with natural gas addition. Fuel, 197, 159-173, 2017.
• Ganesan s, Rathinam S., Sajin J.B., Ganesan S., Yuvarajan D. Performance and emission study on the effect of oxygenated additive in neat biodiesel fueled diesel engine. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 41(16), 2017-2027, 2018.
• Roh H.G., Lee D., Lee C.S. Impact of DME-biodiesel, diesel-biodiesel and diesel fuels on the combustion and emission reduction characteristics of a CI engine according to pilot and single injection strategies. Journal of the Energy Institute, 88(4), 376-385, 2015.
• Singh D., Sharma D., Soni S.L., Sharma S., Kumari D. Chemical compositions, properties, and standards for different generation biodiesels: A review. Fuel, 253, 60-71, 2019.
• Ahmadi M.A., Mostafaei M., Najafi G., Rabbani H. Effect of nano-additives blended diesel-biodiesel on performance and emissions of CI engine in the presence of magnetic field. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 0-0, 1-21, 2019
• Mei D., Sun C., Gu M., Zhang Q., Yuan Y. Physical and chemical properties and thermogravimetric performance of hydrogenated biodiesel. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 39(16), 1739-1745, 2017.
• Sakthivel R., Ramesh K., Purnachandran R., Mohamed Shameer P. A review on the properties, performance and emission aspects of the third generation biodiesels. Renewable and Sustainable Energy Reviews, 82, 2970-2992, 2018.
• Santori G., Di Nicola G., Moglie M., Polonara F. A review analyzing the industrial biodiesel production practice starting from vegetable oil refining. Applied Energy, 92, 109-132, 2012.
• Singh S.P., Singh D. Biodiesel production through the use of different sources and characterization of oils and their esters as the substitute of diesel: A review. Renewable and Sustainable Energy Reviews, 14(1):200-216, 2010.
• Simsek S. Effects of biodiesel obtained from Canola, sefflower oils and waste oils on the engine performance and exhaust emissions. Fuel, 265, 117026, 2020.
• Özcanli M., Serin H., Saribiyik O.Y., Aydin K., Serin S. Performance and Emission Studies of Castor Bean (Ricinus Communis) Oil Biodiesel and Its Blends with Diesel Fuel. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 34(19), 1808-1814, 2012.
• Akram W., Singh Y., Sharma A., Singh N.K. Experimental studies on performance and exhaust emission characteristics of a diesel engine fuelled with diesel-linseed oil methyl ester (LOME) blends. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 0-0, 1-15, 2019.
• Sharma A., Singh Y., Kumar N.A. Effect of fuel injection pressure and timing on Polanga (Calophyllum Inophyllum) biodiesel blends for engine performance and emissions analysis. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 41(24), 3046-3057, 2019.
• Suresh M., Jawahar C.P., Renish R.R, Malmquist A. Performance evaluation and emission characteristics of variable compression ratio diesel engine using Argemone Mexicana biodiesel. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 0-0, 1-13, 2019.
• Pushparaj T., Ramabalan S., Arul Mozhi Selvan V. Performance Evaluation and Exhaust Emission of a Diesel Engine Fueled with CNSL Biodiesel. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 37(18), 2013-2019, 2015.
• Rangabashiam D., Jayaprakash V., Ganesan S., Nagaraj M., Rameshbabu A. Emission, performance, and combustion study on nanoparticle-biodiesel fueled diesel engine. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 0-0, 1-12, 2019.
• Sridharan G., Chandramouli R., Mohamed Musthafa M., Ashok K.T., Performance, combustion and emission characteristics of a single cylinder CI engine running on diesel-biodiesel-water emulsion with additive. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 0-0, 1-14, 2019.