Enhanced Biogas Production in Anaerobic Digestion of Cassava Wastewater Though Supplementation of Biodiesel Waste as Co-substrate

Abstract

Anaerobic co-digestion is an attempt to enhance biogas production and improve the economic efficiency of large scale plant operations. In this work, the biodiesel processing waste (BDW) at different portions of 0.5-3.0% (v/v) in feed was subsequently added to an anaerobic hybrid reactor (AHR) treating cassava wastewater (CSW). Enhanced gases production, optimum dosage, digester’s performance and stability of each co-digestion conditions were evaluated. The results obtained clearly demonstrated the possible co-digestion of these wastes which increased gases production if BDW did not exceed 2.0%. The supplementation of BDW at 0.5-2.0% can increase 19.4-96.2% and 13.4-56.7% for biogas and methane production, respectively. These daily productions of biogas and methane were 12.6, 13.8, 15.5, 20.7, 18.8, 16.4 L-biogas/d and 8.6, 9.4, 10.3, 13.2, 11.0, 7.7 L-CH4/d for 0.5-3.0% BDW addition, compared to 10.6 L-biogas/d and 7.2 L-CH4/d of single CSW digestion. Similar gases yields (0.45-0.51 L-biogas/gCODremoved and 0.30-0.33 L-CH4/gCODremoved) and stable performance of AHR were maintained at 0.5-2.0% additions. The optimal dosage which promoted the maximum production was suggested to be 2.0%. Higher BDW dosage was claimed as the limitation. An imbalance digestion was observed as depicted as drop of pH, lower methane composition, and acid accumulation at particularly 3.0% of BDW supplementation.

Keywords

• renewable energy; biomass energy; biogas

Kaynakça

1. R. J. Frankin, “Full-scale experiences with anaerobic treatment of industrial wastewater”, Wat. Sci. Tech.vol. 44 (8), pp. 1-6, 2001.
2. P. Kullavanijaya, N. Paepatung, O. Laopitinun, A. Noppharatana, P. Chaiprasert, “An overview of status and potential of biomethanation technology in Thailand”, KMUTT Res. J., vol. 30 (4), pp. 694-700, 2007.
3. R. P. J. M. Ravena, K. M. Gregersenb, “Biogas plants in Denmark: successes and setbacks”, Renew. Sust. Energ. Rev., vol. 11, pp. 116-132, 2005.
4. T. Amon, B. Amon, , V. Kryvoruchko, V. Bodiroza, E. Potsch, W. Zollitsch, “Optimising methane yield from anaerobic digestion of manure: effects of dairy systems and of glycerine supplementation”, International Congress Series, vol. 1293, pp. 217-220, 2006.
5. F. J. Callaghan, D. A. J. Wase, K. Thayanithy, C. F. Forster, “Co-digestion of waste organic solids - batch studies” Bioresource. Technol., vol. 67 (2), pp. 117-122, 1999.
6. M. S. Fountoulakis, I. Petousi, T. Manios, “Co-digestion of sewage sludge with glycerol to boost biogas production”, Waste Management, vol. 30, pp. 1849-1853, 2010.
7. N. Kolesarova, M. Hutnan, I. Bodik, V. Spalkova, “Utilization of biodiesel by-products for biogas production”, J. Biomed. Biotech., vol. 2011 (ID: 126798), pp. 1-15, 2011.
8. M. A. Dasaria, P. Kiatsimkula, W. R. Sutterlinb, G. J. Suppes, “Low-pressure hydrogenolysis of glycerol to propylene glycol”, Appl. Catal. A-Gen, vol. 281, pp. 225- 231, 2005.

9. S. P. Singh, D. Singh, “Biodiesel production through the use of different sources and characterization of oils and their esters as the substitute of diesel”, Renew. Sust. Energ. Rev., vol. 14, pp. 200-216, 2010. [10]
10. I. Bodik, M. Hutnan, T. Petheoova, A.Kalina, “Anaerobic treatment of biodiesel production waste”, Proceedings of the Book of Lectures on 5th International Symposium on Anaerobic Digestion of Solid Wastes and Energy Crops, Hammamet, Tunisia, 2008. [11]
11. M. Hutnan, N. Kolesarova, I. Bodık, V. Spalkova, M. Lazor, “Possibilities of anaerobic treatment of crude glycerol from biodiesel production,” Proceedings of 36th International Conference of Slovak Society of Chemical Engineering, Tatranske Matliare, 24-28 May 2009. [12]
12. Wohlgemut O., “Co-Digestion of hog manure with glycerol to boost biogas and methane production” Master Thesis, The University of Manitoba, Minitoba, Canada, 2009. [13]
13. J. Ma, M. V. Wambeke, M. Carballa, W. Verstraete, “Improvement of the anaerobic digestion of potato processing wastewater in a UASB reactor by co-digestion with glycerol”, Biotechnol. Lett. vol. 30(5), pp. 861-867, 2008. [14]
14. B. K. Ahring, M. Sandberg, I. Angelidaki, “Volatile fatty acids as indicators of process imbalance in anaerobic digesters”, Appl. Microbiol. Biot, vol. 43, pp. 559-565, 1995. [15]
15. J. B. Holm-Nielsen, C. J. Lomborg, P. Oleskowicz- Popiel, K. H. Esbensen, “On-line near infrared monitoring of glycerol-boosted anaerobic digestion processes: evaluation of process analytical technologies”, Biotech. Bioeng., vol. 99 (2), pp. 302-313 2008.