An Experimental Study on the Total and Capillary Water Absorption of Mortar Containing Phragmites Australis Ash

Öz

The use of biomass ashes as cement replacement have become a notable and trending aspect due to the huge increase in the pollution levels caused by the manufacturing process of cement. Phragmites Australis Ashes (PAA) can be an eco-friendly alternative to cement since it can be burnt in a closed container decreasing the CO2 emissions into atmosphere. Also, PAA is considered an economical material since it is available locally and grows massively on the banks of the rivers in Lebanon. The performance of mortar mixes produced by a partial replacement of cement were evaluated in this paper revealing a big potential for PAA to be used as cement replacement. Cement in mortar specimens was replaced by 0, 10, 20 and 30% by weight PAA. Mix proportions and water to binder ratio were set constant for all casted mixes. Durability properties, including total water absorption and capillary water absorption, containing different PAA percentages were evaluated at 1, 7, 28 and 90 days of curing ages in comparison to the control specimen. The test results show an increase in the total water absorption percentages as PAA percentage is enhanced in mixes. The same trend was also obtained for capillary water absorption test.

Anahtar Kelimeler

• Sustainability
• bio-ash
• phragmites australis ash
• carbon footprint reduction
• cement replacement

Phragmites Australis Külü İçeren Harcın Toplam ve Kılcal Su Emmesi Üzerine Deneysel Bir Çalışma

Öz

Biyokütle küllerinin çimento yerine kullanılması, çimento üretim sürecinin neden olduğu kirlilik seviyelerindeki büyük artış nedeniyle dikkate değer ve son yıllarda araştırmacılar tarafından önem verilen konular arasına girmiştir. Phragmites Australis Ashes (PAA), kapalı bir kapta yakılarak atmosfere salınan CO2 emisyonunu azalttığı için çimentoya çevre dostu bir alternatif olabilir. Ayrıca PAA, yerel olarak bulunduğundan ve Lübnan'daki nehirlerin kıyılarında yoğun bir şekilde büyüdüğünden ekonomik bir malzeme olarak kabul edilir. Kısmi çimento ikamesi ile üretilen harç karışımlarının performansı, PAA'nın çimento ikamesi olarak kullanılması için büyük bir potansiyel ortaya koyan bu yazıda değerlendirilmiştir. Harç numunelerindeki çimento, ağırlıkça %0, 10, 20 ve %30 PAA ile değiştirilmiştir. Karışım oranları ve su/çimento oranı tüm dökülen karışımlar için sabit tutulmuştur. Farklı PAA yüzdeleri içeren toplam su emme ve kılcal su emme dahil olmak üzere dayanıklılık özellikleri, kontrol numunesine kıyasla 1, 7, 28 ve 90 günlük kürleme yaşlarında değerlendirilmiştir. Test sonuçları, karışımlarda PAA yüzdesi arttıkça toplam su emme yüzdelerinde bir artış olduğunu göstermektedir. Aynı eğilim kılcal su emme testi için de elde edilmiştir.

Anahtar Kelimeler

• Sürdürülebilirlik
• biyo-kül
• phragmites australis külü
• karbon ayak izinin azaltılması
• çimento ikamesi

Kaynakça

1. A. Abitha, C.A. Jesty, S. Siyad, P.C. Vijay, S. Sreerekha Raj, B.S. Dhanya, “Feasibility assessment of rice straw ash as a supplementary cementitious material,” Mater Today-Proc., Jan, 2023.
2. A. Aneja, R.L. Sharma, H. Singh, “Mechanical and durability properties of biochar concrete,” Mater Today-Proc., vol. 65, part 8, pp 3724– 3730, 2022.
3. M.A. Kareem, B.B. Akintonde, J.S. Adesoye, K. Ishola, I.A. Tijani, A.U. Adebanjo, M.O. Thanni, W.O. Oduoye, D.O. Adeyanju, A.A. Bello, “Influence of cashew leaf ash as partial replacement for cement on the properties of fresh and hardened concrete,” Cleaner Waste Systems, vol. 4, no. 100063, Apr, 2023.
4. K. Nandhini, J. Karthikeyan, “Sustainable and greener concrete production by utilizing waste eggshell powder as cementitious material – A review,” Const Build Mater, vol. 335, no. 127482, Jun, 2022.
5. D. Ali, R. Agarwal, M. Hanifa, P. Rawat, R. Paswan, D. Rai, I. Tyagi, B. S. Naik, A. Pippal, “Thermo-physical properties and microstructural behaviour of biocharincorporated cementitious material,” J Build Eng, vol. 64, no. 105695, Apr, 2023.
6. H.Y.B. Katman, W.J. Khai, N. Bheel, M.S. Kırgız, A. Kumar, J. Khatib, O. Benjeddou, “Workability, strength, modulus of elasticity, and permeability feature of wheat straw ashincorporated hydraulic cement concrete,” Buildings, vol. 12, no. 9, Sept, 2022.
7. N. Sathiparan, A. Anburuvel, V. V. Selvam, “Utilization of agro-waste groundnut shell and its derivatives in sustainable construction and building materials – A review,” J Build Eng, vol. 66, no. 105866, May, 2023.
8. M. Shakouri, C. L. Exstrom, S. Ramanathan, P. Suraneni, J. S. Vaux, “Pretreatment of corn stover ash to improve its effectiveness as a supplementary cementitious material in concrete,” Cement Concrete Comp, vol. 12, no. 103658, Sept, 2020.

9. M. Pekgöz, İ. Tekin, “The effects of different origins NaOH on the mechanical and microstructural properties of tuff-based alkaliactivated pastes,” Turk J Eng Res Educ, vol. 1, no. 1, pp. 29-37, 2022.
10. M. H. Javed, M. A. Sikandar, W. Ahmad, M. T. Bashir, R. Alrowais, M. B. Wadud, “Effect of various biochars on physical, mechanical, and microstructural characteristics of cement pastes and mortars,” J Build Eng, vol. 57, no. 104850, Oct, 2022.
11. H. Affan, W. Arairo, J. Arayro, “Mechanical and thermal characterization of bio-sourced mortars made from agricultural and industrial byproducts,” Case Stud Const Mater, vol. 18, no. e01939, Jun, 2023.
12. S.S. Dash, S. P. Mishra, S. Panda, “Physiognomies and strength investigation of concrete part blended by wood ash,” Int. J. Environ. Clim. Change, vol. 11, no. 5, pp. 143- 155, Jul, 2021.
13. M. Sonebi, A. Abdalqader, T. Fayyad, S. Amaziane, J El-Khatib, “Effect of fly ash and metakaolin on the properties of fiber-reinforced cementitious composites: A factorial design approach,” Comput Concrete, vol. 29, no. 5, pp347-360, May, 2022.
14. H. Ghanem J. Khatib A. Elkordi, “Effect of partial replacement of sand by mswi-ba on the properties of mortar,” BAU J Sci Tech, vol. 1, no. 2, 2020.
15. M. Machaka, J. Khatib, A. Elkordi, H. Ghanem, O. Baalbaki, “Selected properties of concrete containing municipal solid waste incineration bottom ash (MSWI-BA),” 5th Int Conf Sust Const Mater Tech (SCMT5), London, UK, 2019, pp. 14-17.
16. N. N. A. Rasid, N. H. A Khalid, A. Mohamed, A. R. M. Sam, Z. A. Majid, G. F. Huseien, “Ground palm oil fuel ash and calcined eggshell powder as SiO2–CaO based accelerator in green concrete,” J Build Eng, vol. 15, no. 105617, Apr, 2023.
17. H. Ghanem, M. Machaka, J. Khatib, A. Elkordi, O. Baalbaki, “Effect of partial replacement of cement by MSWIBA on the properties of mortar,” Acad J Civ Eng, vol. 37, no. 2, pp. 82- 89, Jun, 2019.
18. K. Nandhini, J. Karthikeyan, “Effective utilization of waste eggshell powder in cement mortar, Mater Today-Proc, vol. 61, no. 2, pp. 428 – 432, Jan, 2022.
19. F. Wu, Q. Yu, H. J. Brouwers, “Long-term performance of bio-based miscanthus mortar,” Const Build Mater, vol.21, no. 126703, Mar, 2022.
20. M. Machaka, J. Khatib, S. Baydoun, A. Elkordi, J. J. Assaad, “The effect of adding phragmites australis fibers on the properties of concrete,” Buildings., vol. 12(3), no. 278, Mar, 2022.
21. M. Machaka, A. Elkordi, H. Ghanem, J. Khatib, O. Baalbaki, “Selected properties of concrete containing palm fibers,” Acad J Civ Eng, vol. 37, no. 2, pp. 279-286, Jun, 2019.
22. B. S. Thomas, J. Yang, K. H. Mo, J. A. Abdalla, R. A. Hawileh, E. Ariyachandra, “Biomass ashes from agricultural wastes as supplementary cementitious materials or aggregate replacement in cement/geopolymer concrete: A comprehensive review,” J Build Eng, vol. 40, no. 102332, Aug, 2021.
23. J. He, S. Kawasaki, V. Achal, “The utilization of agricultural waste as agro-cement in concrete: A review,” Sustainability, vol. 12, no. 6971, Aug, 2020.
24. L. ElKhatib, F. A. Aridi, A. ElKordi, J. Khatib, “Mechanical and durability properties of geopolymer concrete– A Review, “ BAU J Sci Tech, vol. 3, no. 8, 2022.
25. L. ElKhatib, F. A. Aridi, A. ElKordi, Adel, Khatib, Jamal M., “Selected properties on geopolymer concrete – A review,” III International Turkish World Engineering and Science Congress, 2021, pp. 337-345.
26. V.T. de Sande, M. Sadique, A. Bras, P. Pineda, “Activated sugarcane bagasse ash as efficient admixture in cement-based mortars: Mechanical and durability improvements,” J Build Eng, vol. 59, no. 105082. Nov, 2022.
27. B. Patnaik, J. Chimdi, T. S. Sekhar, “Bermuda grass ash as a sustainable cementing material in concrete for ethiopian construction industry,” Mater Today-Proc, vol. 1, no. 62, pp. 7261-7264, Jan, 2022.