ANAEROBİK ÇÜRÜTÜCÜ ATIKSULARININ MİKROALG REAKTÖRLERİNDE ARITILMASI

Yıl 2019, Cilt: 24 Sayı: 3, 89 - 108, 31.12.2019

Ülker Diler Keriş Şen

https://doi.org/10.17482/uumfd.530127

Öz

Bu çalışma evsel nitelikli anaerobik çürütücü atıksuyunun (AÇAS) evsel nitelikli atık suların alıcı
ortam deşarj standartlarına uygun düzeyde arıtılmasında bakteri ve mikroalg kültürlerinin birlikte ve ayrı
ayrı kullanılmasının arıtım verimliliği üzerindeki etkisini incelemek üzere yürütülmüştür. Bakteri ve
mikroalg kültürlerinin birlikte kullanıldığı, AÇAS içeriğinin kademeli olarak arıtma tesisi deşarj suyu
(AD) ile seyreltilerek işletilen reaktörlerde ulaşılan arıtım verimleri kimyasal oksijen ihtiyacı (KOİ) için
%87,9, toplam organik karbon (TOK) için %86,6 ve inorganik karbon (İK) için %84,6 olmuştur. Bununla
birlikte atıksu muhtevasındaki fosfatın (PO4
3-
-P) %84’ü ve toplam azotun (TA) %100’ü giderilmiştir.
Diğer taraftan bakteri ve mikroalg kültürlerinin ayrı ayrı kullanılmasının karşılaştırıldığı deneylerde
mikroalglerin, atıksu arıtımında bakterilerden daha iyi bir arıtım sağladığı ancak her iki mikroorganizma
topluluğunun birlikte kullanılmasının çok daha etkin bir arıtım sağladığı tespit edilmiştir. Çalışma
sonunda Türkiye Su Kirliliği Kontrolü Yönetmeliği Evsel Nitelikli Atık Suların Alıcı Ortam Deşarj
Standartlarına (Sınıf: 3) uygun düzeyde arıtım sağlanmıştır.

Anahtar Kelimeler

Mikroalg, Anaerobik Çürütücü, Atıksu Arıtımı

Treatment of Anaerobic Digestion Effluent in Microalgal Bioreactors

Öz

This study was performed to investigate the effect of combined and separate use of bacteria
and microalgae cultures on the efficiency of the treatment domestic anaerobic digestion (AD) effluent to
meet the domestic wastewater discharge standards. AD effluent was diluted with waste water treatment
plant discharge in different proportions in separate reactors and the treatment efficiency of reactors was
compared regarding nutrient removal yields. The highest treatment efficiency was obtained with
combined use of bacteria and microalgae cultures and corresponding removal efficiencies were 87.9% for
COD, 86.6% for TOC, 84.6% for IC, 84% for orthophosphates and for 100% total nitrogen. On the other
hand, it was found that although the treatment efficiencies in the reactors including only microalgae
cultures are higher than those including only bacterial cultures, and the combined use of microalgal and
bacteria cultures still has the highest treatment efficiency among others at the end of the study, AD
effluent was successfully treated according the Turkey Water Pollution Control Regulation Domestic
Wastewater Discharge Standards (Class:3). 

Anahtar Kelimeler

Microalgae, Anaerobic Digestion, Wastewater Treatment

Kaynakça

• Chang, H., APHA 2005. Standard Methods for the Examination of Water and Wastewater. 21st Edition, American Public Health Association, Washington DC, USA.
• Bouterfas, R., Belkoura, M., Dauta, A. 2002. Light and temperature effects on the growth rate of three freshwater algae isolated from a eutrophic lake., Hydrobiologia 489, 207–217. doi: 10.1023/A:1023241006464:
• Cai, T., Ge, X., Park, S. Y., Li, Y. 2013(a). Comparison of Synechocystis sp. PCC6803 and Nannochloropsis salina for lipid production using artificial seawater and nutrients from anaerobic digestion effluent. Bioresource Technology, 144,255-260. doi: 10.1016/j.biortech.2013.06.101.
• Cai, T., Park, S. Y., Racharaks, R., Li, Y. 2013(b). Cultivation of Nannochloropsis salina using anaerobic digestion effluent as a nutrient source for biofuel production. Applied Energy, 108, 486-492. doi: 10.1016/j.apenergy.2013.03.056
• Cheng, J., Ye, Q., Xu, J., Yang, Z., Zhou, J., Cen, K. 2016. Improving pollutants removal by microalgae Chlorella PY-ZU1 with 15%CO2 from undiluted anaerobic digestion effluent of food wastes with ozonation pretreatment. Bioresource Technology, 216, 273-279. doi:10.1016/j.biortech.2016.05.069
• Cheng, J., Xu, J., Huang, Y., Li, Y., Zhou, J., Cen, K. 2015. Growth optimisation of microalga mutant at high CO2 concentration to purify undiluted anaerobic digestion effluent of swine manure. Bioresource Technology, 177, 240-246. doi: 10.1016/j.biortech.2014.11.099
• De˛bowski M., Szwaja S., Zielin´ski M., Kisielewska M., Stan´czyk-Mazanek E. 2017. The influence of anaerobic digestion effluents (ADEs) used as the nutrient sources for Chlorella sp. cultivation on fermentative biogas production. Waste Biomass Valor, 8, 1153–1161. doi: 10.1007/s12649-016-9667-1
• Deng, X. Y., Gao, K., Zhang, R. C., Addy, M., Lu, Q., Ren, H. Y., ... & Ruan, R. 2017. Growing Chlorella vulgaris on thermophilic anaerobic digestion swine manure for nutrient removal and biomass production. Bioresource technology, 243, 417-425. doi: 10.1016/j.biortech.2017.06.141
• Gürol, M. D., Özkan, M., Yatmaz, C., Keriş-Sen, Ü.D., Soydemir, G., Say, N., Sen, Ü. 2013. Mikroalglerden biyodizel üretiminde yenilikçi (innovative) yaklaşımlar, TÜBİTAK 1001 Projesi, Proje No:109Y296.
• Hajar, H.A.A., Riefler, R.G. and Stuart, B.J., 2016. Anaerobic digestate as a nutrient medium for the growth of the green microalga Neochloris oleoabundans. Environmental Engineering Research, 21(3), 265-275.doi: doi.org/10.4491/eer.2016.005
• Hajar, H.A.A., Riefler, R.G. and Stuart, B.J., 2017. Cultivation of Scenedesmus dimorphus using anaerobic digestate as a nutrient medium. Bioprocess and biosystems engineering, 40(8), 1197-1207. doi: 10.1007/s00449-017-1780-4
• Hulatt C. J., Lakaniemi A. M., Puhakka J. A., Thomas D. N. 2012. Energy demands of nitrogen supply in mass cultivation of two commercially important microalgal species, Chlorella vulgaris and Dunaliella tertiolecta. Bioenergy Research, 5(3), 669-684. doi: 10.1007/s12155-011-9175-x
• Ji, F., Liu, Y., Hao, R., Li, G., Zhou, Y., Dong, R. 2014. Biomass production and nutrients removal by a new microalga strain Desmodesmus sp. in anaerobic digestion wastewater. Bioresource Technology, 161, 200-207. doi:doi.org/10.1016/j.biortech.2014.03.034
• Keris-Sen, U.D., Sen, U., Soydemir, G. and Gurol, M.D., 2014. An investigation of ultrasound effect on microalgal cell integrity and lipid extraction efficiency. Bioresource technology, 152, 407-413. doi: 10.1016/j.biortech.2013.11.018
• Keris-Sen, U.D. and Gurol, M.D., 2017. Using ozone for microalgal cell disruption to improve enzymatic saccharification of cellular carbohydrates. Biomass and Bioenergy, 105, 59-65. doi: 10.1016/j.biombioe.2017.06.023
• Keriş-Şen, Ü. D. 2016. Mikroalglerin sudan ayrıştırılmasında ve biyoetanol üretiminde ozon ve ultrases kullanımı. Doktora Tezi, Gebze Teknik Üniversitesi, Fen Bilimleri Enstitüsü, Kocaeli
• Kong Q., Li L., Martinez B., Chen P., Ruan R. 2010. Culture of microalgae Chlamydomonas Reinhardtii in wastewater for biomass feedstock production, Applied Biochemistry and Biotechnology, 160 (1), 9-18. doi://doi.org/10.1007/s12010-009-8670-4
• Levine R. B., Costanza-Robinson M. S., Spatafora G. A. 2011. Neochloris oleoabundans grown on anaerobically digested dairy manure for concomitant nutrient removal and biodiesel feedstock production, Biomass Bioenergy 35, 40-49. doi: 10.1016/j.biombioe.2010.08.035
• Li, Y., Chen, Y.F., Chen, P., Min, M., Zhou, W., Martinez, B., Zhu, J. and Ruan, R., 2011. Characterization of a microalga Chlorella sp. well adapted to highly concentrated municipal wastewater for nutrient removal and biodiesel production. Bioresource technology, 102(8), 5138-5144. doi: 10.1016/j.biortech.2011.01.091
• Li Y.R., Tsai W.T., Hsu Y.C., Xie M.Z., Chen J.J. 2014. Comparison of autotrophic and mixotrophic cultivation of green microalgal for biodiesel production. Energy Procedia 52 371–376. doi: 10.1016/j.egypro.2014.07.088
• Mandal S., Mallick N. 2009. Microalga Scenedesmus obliquus as a potential source for biodiesel production. Appl Microbiol Biot, 84(2), 281-291.doi: 10.1007/s00253-009-1935-6
• Mohammad Mirzaie M.A., Kalbasi M., Mousavi S.M., Ghobadian B. 2016. Investigation of mixotrophic, heterotrophic, and autotrophic growth of Chlorella vulgaris under agricultural waste medium. Prep Biochem Biotechnol. 2016;46(2):150-6. doi: 10.1080/10826068.2014.995812
• Park, J., Jin, H. F., Lim, B. R., Park, K. Y., & Lee, K. 2010. Ammonia removal from anaerobic digestion effluent of livestock waste using green alga Scenedesmus sp. Bioresource technology, 101(22), 8649-8657. doi: 10.1016/j.biortech.2010.06.142
• Pittman J. K., Dean A. P., Osundeko O. 2011. The potential of sustainable algal biofuel production using wastewater resources. Bioresource Technology, 102(1), 17-25. doi: 10.1016/j.biortech.2010.06.035
• Pruvost J., Van Vooren G., Le Gouic B., Couzinet-Mossion A., Legrand J. 2011. Systematic investigation of biomass and lipid productivity by microalgae in photobioreactors for biodiesel application. Bioresource Technology, 102(1), 150-158. doi: 10.1016/j.biortech.2010.06.153
• Rippka, R., Deruelles, J., Waterbury, J.B., Herdman, M. and Stanier, R.Y., 1979. Generic assignments, strain histories and properties of pure cultures of cyanobacteria. Microbiology, 111(1), pp.1-61. doi: 10.1099/00221287-111-1-1
• Singh, M., Reynolds, D. L., Das, K. C. 2011. Microalgal system for treatment of effluent from poultry litter anaerobic digestion, Bioresource Technology, 102(23), 10841-10848. doi: 10.1016/j.biortech.2011.09.037
• Su Kirliliği Kontrolü Yönetmeliği, Resmî Gazete Tarihi: 31.12.2004 Resmî Gazete Sayısı: 25687 http://www.resmigazete.gov.tr/eskiler/2008/02/20080213-13.htm (Erişim Tarihi 12/2/2019)
• Sydney E. B., da Silva T. E., Tokarski A., Novak A. C., de Carvalho J. C., Woiciecohwski A. L., Larroche C., Soccol C. R. 2011. Screening of microalgae with potential for biodiesel production and nutrient removal from treated domestic sewage. Applied Energy, 88 (10), 3291-3294. doi: 10.1016/j.apenergy.2010.11.024
• Tan, X., Chu, H., Zhang, Y., Yang, L., Zhao, F., Zhou, X. 2014. Chlorella pyrenoidosa cultivation using anaerobic digested starch processing wastewater in an airlift circulation photobioreactor. Bioresource Technology, 170, 538-548. doi: 10.1016/j.biortech.2014.07.086
• Uggetti, E., Sialve, B., Latrille, E., Steyer, J.-P. 2014. Anaerobic digestate as substrate for microalgae culture: The role of ammonium concentration on the microalgae productivity. Bioresource Technology, 152, 437-443. doi: 10.1016/j.biortech.2013.11.036
• Vaneeckhaute, C., Meers, E., Michels, E., Christiaens, P., Tack, F. M. G. 2012. Fate of macronutrients in water treatment of digestate using vibrating reversed osmosis, Water, Air, & Soil Pollution, 223(4), 1593-1603. doi: 10.1007/s11270-011-0967-6
• Wang, H., Zhang, W., Chen, L., Wang, J., Liu, T. 2013. The contamination and control of biological pollutants in mass cultivation of microalgae. Bioresource Technology, 128, 745-750. doi: 10.1016/j.biortech.2012.10.158
• Wang, L., Wang, Y., Chen, P., Ruan, R. 2010. Semi-continuous cultivation of Chlorella vulgaris for treating undigested and digested dairy manures, Applied Biochemistry and Biotechnology, 162(8), 2324-2332. doi: 10.1007/s12010-010-9005-1
• Xia, A., Murphy, J. D. 2016. Microalgal cultivation in treating liquid digestate from biogas systems. Trends in Biotechnology, 34(4), 264-275. doi: 10.1016/j.tibtech.2015.12.010
• Xu, J., Zhao, Y., Zhao, G., Zhang, H. 2015. Nutrient removal and biogas upgrading by integrating freshwater algae cultivation with piggery anaerobic digestate liquid treatment. Applied Microbiology and Biotechnology, 99(15), 6493-6501.doi:10.1007/s00253-015-6537-x
• Yang, S., Xu, J., Wang, Z.M., Bao, L.J. and Zeng, E.Y., 2017. Cultivation of oleaginous microalgae for removal of nutrients and heavy metals from biogas digestates. Journal of Cleaner Production, 164, 793-803. doi: 10.1016/j.jclepro.2017.06.221
• Yang, L., Tan, X., Li, D., Chu, H., Zhou, X., Zhang, Y., & Yu, H. 2015. Nutrients removal and lipids production by Chlorella pyrenoidosa cultivation using anaerobic digested starch wastewater and alcohol wastewater. Bioresource technology, 181, 54-61. doi: 10.1016/j.biortech.2015.01.043