Green-synthesised silver nanoparticle-loaded alginate/gelatin/aloe vera nanocomposite hydrogel films as wound dressings

Abstract

Open wounds resulting from trauma, burns or complications of diabetes require dressings that keep the wound bed moist, limit infection and remain compatible with host tissue. Many reported hydrogel dressings satisfy some of these requirements but are limited by high cost, complex synthesis, weak mechanical behaviour or poor cytocompatibility. Although alginate, gelatin, Aloe vera and silver nanoparticles have each been used individually in dressing materials, their combination into a single, low-cost film, and the systematic study of how the alginate-to-gelatin ratio governs its properties with green-synthesised AgNPs, has not previously been reported. In this study, three nanocomposite hydrogel films based on alginate, gelatin and Aloe vera were prepared at ALG/GEL/AV mass ratios of 1/3/20, 2/2/20 and 3/1/20 (coded AGA13, AGA22 and AGA31, respectively), crosslinked with Ca²⁺ and loaded with 1% (w/w) silver nanoparticles. The AgNPs were green synthesised by reducing AgNO₃ with pomegranate (Punica granatum) extract; they were spherical, approximately 50-150 nm in size, with a mean hydrodynamic radius of 162.76 nm and a zeta potential of -41.83 mV, indicating a stable, weakly aggregating dispersion. Film behaviour was largely governed by the alginate content. As the alginate fraction increased, the films became denser and swelled less, so that equilibrium swelling and water retention both decreased in the order AGA13>AGA22>AGA31, with AGA13 reaching approximately 150% swelling and 65% water retention. Ethanol displacement indicated negligible open porosity for all films, in line with SEM. Over four weeks the films lost mass from about 78% (AGA13) to below 40% (AGA31), a range wide enough to match dressing lifetime to the intended application. None of the formulations was cytotoxic to L-929 fibroblasts in the indirect MTT assay, with viabilities of 115%, 110% and above 130% for AGA13, AGA22 and AGA31 relative to the control. Overall, AGA31 combined the slowest mass loss with the strongest fibroblast response, identifying it as the most suitable candidate for longer-term wound management.

Keywords

• Alginate
• Aloe vera
• hydrogel
• gelatin
• silver nanoparticle
• wound dressing

Project Number

059-2021

Thanks

This study was supported by the Scientific Research Projects Unit of Sakarya University of Applied Sciences (Project No. 059-2021).

References

1. Aderibigbe, B. A., & Buyana, B. (2018). Alginate in Wound Dressings. Pharmaceutics, 10(2), 42.
2. Aldakheel, F. M., Wickramasinghe, R., Thamaraiselvan, C., Sayed, M. M. E., Fagir, M. H., Dein, D. K. E., & Mohsen, D. (2025). Green silver nanoparticle-embedded chitosan-alginate hydrogel: A novel antibacterial approach for potential wound healing. Polymers and Polymer Composites, 33. https://doi.org/10.1177/09673911251320463
3. Arab, A., Orakci, V., & Erbilen, M. (1994). Yara Iyilesmesi. Journal of Turgut Ozal Medical Center, 1(2), 160-166.
4. Ates, B., Koytepe, S., Balcioglu, S., Karaaslan, M. G., Kelestemur, U., Gulgen, S., & Ozhan, O. (2019). Biomimetic approach to tunable adhesion of polyurethane adhesives through Fe3+ crosslinking and hydrophobic tween units with balance of adhesion/cohesion forces. International Journal of Adhesion and Adhesives, 95.
5. Baruah, A., Bordoloi, M., & Deka Baruah, H. P. (2016). Aloe vera: A multipurpose industrial crop. Industrial Crops and Products, 94, 951-963. https://doi.org/10.1016/j.indcrop.2016.08.034
6. Boateng, J. S., Matthews, K. H., Stevens, H. N. E., & Eccleston, G. M. (2008). Wound Healing Dressings and Drug Delivery Systems: A Review. Journal of Pharmaceutical Sciences, 97(8), 2892-2923.
7. Broughton, G., Janis, J. E., & Attinger, C. E. (2006). The basic science of wound healing. Plastic and Reconstructive Surgery, 117(7 Suppl), 12S-34S. https://doi.org/10.1097/01.prs.0000225430.42531.c2
8. Burusapat, C., Supawan, M., Pruksapong, C., Pitiseree, A., & Suwantemee, C. (2018). Topical aloe vera gel for accelerated wound healing of split-thickness skin graft donor sites: A double-blind, randomized, controlled trial and systematic review. Plastic and Reconstructive Surgery, 142(1), 217-226. https://doi.org/10.1097/PRS.0000000000004515

9. Calis, M., Irmak, G., Demirtas, T. T., Kara, M., Ustun, G. G., Gumusderelioglu, M., Turkkani, A., Cakar, A. N., & Ozgur, F. (2021). Photobiomodulation combined with adipose-derived stem cells encapsulated in methacrylated gelatin hydrogels enhances in vivo bone regeneration. Lasers in Medical Science.
10. Chaubey, P., Gautam, M., Dubey, G., Singh, P. K., Kumar, A., Dwivedi, A., & Kumar, S. (2026). Eco-friendly Green Synthesis of Silver Nanoparticles from Aloe vera Leaf Extract: Characterisation and Antibacterial Evaluations. Journal of Ecophysiology and Occupational Health, 267-276. https://doi.org/10.18311/JEOH/2026/52793
11. Cheng, H., Shi, Z., Yue, K., Huang, X., Xu, Y., Gao, C., Yao, Z., Zhang, Y. S., & Wang, J. (2021a). Sprayable hydrogel dressing accelerates wound healing with combined reactive oxygen species-scavenging and antibacterial abilities. Acta Biomaterialia, 124, 219-232.
12. Cheng, W., Wang, M., Chen, M., Niu, W., Li, Y., Wang, Y., Luo, M., Xie, C., Leng, T., & Lei, B. (2021b). Injectable antibacterial antiinflammatory molecular hybrid hydrogel dressing for rapid MDRB-infected wound repair and therapy. Chemical Engineering Journal, 409. https://doi.org/10.1016/j.cej.2020.128140
13. Contardi, M., Kossyvaki, D., Picone, P., Summa, M., Guo, X., Heredia-Guerrero, J. A., Giacomazza, D., Carzino, R., Goldoni, L., Scoponi, G., Rancan, F., Bertorelli, R., Di Carlo, M., Athanassiou, A., & Bayer, I. S. (2021). Electrospun polyvinylpyrrolidone (PVP) hydrogels containing hydroxycinnamic acid derivatives as potential wound dressings. Chemical Engineering Journal, 409.
14. Cruse, P. J. E., & Foord, R. (1980). The Epidemiology of Wound Infection: A 10-Year Prospective Study of 62,939 Wounds. Surgical Clinics of North America, 60(1), 27-40.
15. Das, S., Mishra, B., Gill, K., Ashraf, M. S., Singh, A. K., Sinha, M., Sharma, S., Xess, I., Dalal, K., Singh, T. P., & Dey, S. (2011). Isolation and characterization of novel protein with anti-fungal and anti-inflammatory properties from Aloe vera leaf gel. International Journal of Biological Macromolecules, 48(1), 38-43.
16. Dehli, F., Southan, A., Drenckhan, W., & Stubenrauch, C. (2021). Tailoring and visualising pore openings in gelatin-based hydrogel foams. Journal of Colloid and Interface Science, 588, 326-335.
17. Deng, J., Li, P. Y., & Cheng, H. (2017). Advances of Smart Materials for Wound Healing. In Smart Materials for Tissue Engineering (pp. 258-289). Royal Society of Chemistry.
18. ElTatawy, R. A., Ismail, A. M., Ayoup, M. S., Ismail, M. M. F., & Fetouh, H. A. (2024). Preparation and kinetic studies of a new antibacterial sodium alginate gelatin hydrogel composite. Scientific Reports, 14(1), 29206. https://doi.org/10.1038/s41598-024-80453-8
19. Farzamfar, S., Aleahmad, M., Kouzehkonan, G. S., Salehi, M., & Nazeri, N. (2021). Polycaprolactone/gelatin nanofibrous scaffolds for tissue engineering. Biointerface Research in Applied Chemistry, 11(4), 11104-11115. https://doi.org/10.33263/BRIAC114.1110411115
20. Fayyazbakhsh, F., Khayat, M. J., & Leu, M. C. (2022). 3D-Printed Gelatin-Alginate Hydrogel Dressings for Burn Wound Healing: A Comprehensive Study. International Journal of Bioprinting, 8(4), 274-291. https://doi.org/10.18063/IJB.V8I4.618
21. Ferrag, C., Li, S., Jeon, K., Andoy, N. M., Sullan, R. M. A., Mikhaylichenko, S., & Kerman, K. (2021). Polyacrylamide hydrogels doped with different shapes of silver nanoparticles: Antibacterial and mechanical properties. Colloids and Surfaces B: Biointerfaces, 197.
22. Gangwar, R., Rao, K. T., Khatun, S., Rengan, A. K., Subrahmanyam, C., & Vanjari, S. R. K. (2025). Aloe vera-driven green synthesis of silver nanoparticles: a facile approach for superior antibacterial activity and enhanced wound-healing. Applied Nanoscience, 15(3), 18.
23. He, J., Liang, Y., Shi, M., & Guo, B. (2020). Anti-oxidant electroactive and antibacterial nanofibrous wound dressings based on poly(ε-caprolactone)/quaternized chitosan-graft-polyaniline for full-thickness skin wound healing. Chemical Engineering Journal, 385, 123464.
24. He, Y., Li, Y., Sun, Y., Zhao, S., Feng, M., Xu, G., Zhu, H., Ji, P., Mao, H., He, Y., & Gu, Z. (2021). A double-network polysaccharide-based composite hydrogel for skin wound healing. Carbohydrate Polymers, 261. https://doi.org/10.1016/j.carbpol.2021.117870
25. Huang, W., Ying, R., Wang, W., Guo, Y., He, Y., Mo, X., Xue, C., & Mao, X. (2020). A Macroporous Hydrogel Dressing with Enhanced Antibacterial and Anti-Inflammatory Capabilities for Accelerated Wound Healing. Advanced Functional Materials, 30(21), 2000644.
26. Kang, M. C., Kim, S. Y., Kim, Y. T., Kim, E. A., Lee, S. H., Ko, S. C., Wijesinghe, W. A. J. P., Samarakoon, K. W., Kim, Y. S., Cho, J. H., Jang, H. S., & Jeon, Y. J. (2014). In vitro and in vivo antioxidant activities of polysaccharide purified from aloe vera (Aloe barbadensis) gel. Carbohydrate Polymers, 99, 365-371.
27. Kim, S., Park, S.-G., Kang, S.-W., & Lee, K. J. (2016). Nanofiber-Based Hydrocolloid from Colloid Electrospinning Toward Next Generation Wound Dressing. Macromolecular Materials and Engineering, 301(7), 818-826. https://doi.org/10.1002/mame.201600002
28. Kumar, R., Singh, A. K., Gupta, A., Bishayee, A., & Pandey, A. K. (2019). Therapeutic potential of Aloe vera—A miracle gift of nature. Phytomedicine, 60. https://doi.org/10.1016/j.phymed.2019.152996
29. Lee, Y. H., Hong, Y. L., & Wu, T. L. (2021). Novel silver and nanoparticle-encapsulated growth factor co-loaded chitosan composite hydrogel with sustained antimicrobility and promoted biological properties for diabetic wound healing. Materials Science and Engineering C, 118. https://doi.org/10.1016/j.msec.2020.111385
30. Li, S., Dong, S., Xu, W., Tu, S., Yan, L., Zhao, C., Ding, J., & Chen, X. (2018). Antibacterial Hydrogels. Advanced Science, 5(5), 1700527. https://doi.org/10.1002/advs.201700527
31. Li, Z. W., Li, C. W., Wang, Q., Shi, S. J., Hu, M., Zhang, Q., Cui, H. H., Sun, J. Bin, Zhou, M., Wu, G. L., Dang, J. Z., & Lu, L. C. (2017). The cellular and molecular mechanisms underlying silver nanoparticle/chitosan oligosaccharide/poly(vinyl alcohol) nanofiber-mediated wound healing. Journal of Biomedical Nanotechnology, 13(1), 17–34. https://doi.org/10.1166/jbn.2017.2324
32. Liang, Y., Zhao, X., Hu, T., Han, Y., & Guo, B. (2019). Mussel-inspired, antibacterial, conductive, antioxidant, injectable composite hydrogel wound dressing to promote the regeneration of infected skin. Journal of Colloid and Interface Science, 556, 514-528. https://doi.org/10.1016/j.jcis.2019.08.083
33. Liknaw, T., Belay, Y., Ramesh, R., & Reddy, R. P. (2025). Aloe vera leaf extract as a sustainable route for silver nanoparticle synthesis with enhanced antimicrobial activity. Scientific Reports, 15(1), 22481. https://doi.org/10.1038/s41598-025-05070-5
34. Lin, L. X., Wang, P., Wang, Y. T., Huang, Y., Jiang, L., & Wang, X. M. (2016). Aloe vera and Vitis vinifera improve wound healing in an in vivo rat burn wound model. Molecular Medicine Reports, 13(2), 1070-1076. https://doi.org/10.3892/mmr.2015.4681
35. Liu, Y., Sui, Y., Liu, C., Liu, C., Wu, M., Li, B., & Li, Y. (2018). A physically crosslinked polydopamine/nanocellulose hydrogel as potential versatile vehicles for drug delivery and wound healing. Carbohydrate Polymers, 188, 27-36. https://doi.org/10.1016/j.carbpol.2018.01.093
36. Lotfinia, F., Norouzi, M. R., Ghasemi-Mobarakeh, L., & Naeimirad, M. (2023). Anthocyanin/Honey-Incorporated Alginate Hydrogel as a Bio-Based pH-Responsive/Antibacterial/Antioxidant Wound Dressing. Journal of Functional Biomaterials, 14(2), 72. https://doi.org/10.3390/JFB14020072
37. Mahmoudi, C., Tahraoui Douma, N., Mahmoudi, H., Iurciuc, C. E., Popa, M., Hamcerencu, M., & Andritoiu, C. V. (2024). Developing and Characterizing a Biocompatible Hydrogel Obtained by Cross-Linking Gelatin with Oxidized Sodium Alginate for Potential Biomedical Applications. Polymers, 16(22), 3143. https://doi.org/10.3390/POLYM16223143
38. Maikovych, O., Pasetto, P., Nosova, N., Kudina, O., Ostapiv, D., Samaryk, V., & Varvarenko, S. (2025). Functional Properties of Gelatin–Alginate Hydrogels for Use in Chronic Wound Healing Applications. Gels, 11(3), 174. https://doi.org/10.3390/GELS11030174/S1
39. Makvandi, P., Ashrafizadeh, M., Ghomi, M., Najafi, M., Hossein, H. H. S., Zarrabi, A., Mattoli, V., & Varma, R. S. (2021). Injectable hyaluronic acid-based antibacterial hydrogel adorned with biogenically synthesized AgNPs-decorated multi-walled carbon nanotubes. Progress in Biomaterials, 10(1), 77-89. https://doi.org/10.1007/s40204-021-00155-6
40. Makvandi, P., Wang, C., Zare, E. N., Borzacchiello, A., Niu, L., & Tay, F. R. (2020). Metal-Based Nanomaterials in Biomedical Applications: Antimicrobial Activity and Cytotoxicity Aspects. Advanced Functional Materials, 30(22), 1910021. https://doi.org/10.1002/adfm.201910021
41. Mallah, S. Z., Malik, U. S., Arshad, Z., Jahan, Z., Bandyopadhyay, S., & Niazi, M. B. K. (2025). Antibacterial Bilayer Hydrogel Dressing for Effective Wound Management: Synthesis and Characterization. BioNanoScience, 15(4), 581.
42. Miroddi, M., Navarra, M., Calapai, F., Mancari, F., Giofre, S. V., Gangemi, S., & Calapai, G. (2015). Review of clinical pharmacology of Aloe vera L. in the treatment of psoriasis. Phytotherapy Research, 29(5), 648-655. https://doi.org/10.1002/ptr.5316
43. Mohil, R. (2012). Classification of Wounds. In S. Sarabahi & V. Tiwari (Eds.), Principles and Practice Of Wound Care (1st ed., pp. 42-48). Jaypee Brothers: Medical Publisher.
44. Moradi, M., Pormohammad, A., Luong, C., & Turner, R. J. (2026). In Vitro and In Vivo Comparison of a Novel Antimicrobial Wound Hydrogel With Commercial Wound Treatments: Antimicrobial, Antibiofilm and Biocompatibility Assessment. International Wound Journal, 23(4), e70904. https://doi.org/10.1111/IWJ.70904
45. Pothuraju, R., Sharma, R. K., Onteru, S. K., Singh, S., & Hussain, S. A. (2016). Hypoglycemic and Hypolipidemic Effects of Aloe vera Extract Preparations: A Review. Phytotherapy Research, 30(2), 200-207. https://doi.org/10.1002/ptr.5532
46. Qing, X., He, G., Liu, Z., Yin, Y., Cai, W., Fan, L., & Fardim, P. (2021). Preparation and properties of polyvinyl alcohol/N–succinyl chitosan/lincomycin composite antibacterial hydrogels for wound dressing. Carbohydrate Polymers, 261. https://doi.org/10.1016/j.carbpol.2021.117875
47. Ragab, A., El-Badry, N., Tamer, N., Naas, A., Hamdy, A., Tawakey, S. H., Hassan, A. H. A., & Salim, A. I. (2025). Biodegradable chitosan/PVA-based hydrogel incorporating green synthesized silver nanoparticles for wound healing applications. BMC Chemistry, 19(1), 190. https://doi.org/10.1186/S13065-025-01564-5
48. Sanchez, M., Gonzalez-Burgos, E., Iglesias, I., & Gomez-Serranillos, M. P. (2020). Pharmacological update properties of aloe vera and its major active constituents. Molecules, 25(6). https://doi.org/10.3390/molecules25061324
49. Shakib, Z., Shahraki, N., Razavi, B. M., & Hosseinzadeh, H. (2019). Aloe vera as an herbal medicine in the treatment of metabolic syndrome: A review. Phytotherapy Research, 33(10), 2649-2660. https://doi.org/10.1002/ptr.6465
50. Sharma, S., Bose, A., Biswas, S., Sen, S., & Roy, I. (2025). Cyperus rotundus mediated green synthesis of silver nanoparticles for antibacterial wound dressing applications. Scientific Reports, 15(1), 18394. https://doi.org/10.1038/s41598-025-03555-x
51. Shen, J., Zhou, Z., Chen, D., Wang, Y., He, Y., Wang, D., & Qin, J. (2021). Poly(aspartic acid) based self-healing hydrogels with antibacterial and light-emitting properties for wound repair. Colloids and Surfaces B: Biointerfaces, 200. https://doi.org/10.1016/j.colsurfb.2021.111568
52. Singab, A. N. B., El-Hefnawy, H. M., Esmat, A., Gad, H. A., & Nazeam, J. A. (2015). A Systemic Review on Aloe arborescens Pharmacological Profile: Biological Activities and Pilot Clinical Trials. Phytotherapy Research, 29(12), 1858–1867. https://doi.org/10.1002/ptr.5483
53. Singer, A. J., & Clark, R. A. F. (1999). Cutaneous Wound Healing. New England Journal of Medicine, 341(10), 738-746. https://doi.org/10.1056/NEJM199909023411006
54. Singer, A. J., & Dagum, A. B. (2008). Current Management of Acute Cutaneous Wounds. New England Journal of Medicine, 359(10), 1037-1046. https://doi.org/10.1056/NEJMra0707253
55. Singh, K., Yadav, V. B., Rai, M., Nath, G., Srivastava, A., Saxena, P. S., & Singh, A. V. (2026). Green-synthesized silver-alginate-ciprofloxacin hydrogel: A multifaceted therapeutic for enhanced diabetic and burn Wound healing. Journal of Biomaterials Applications, 41(2), 285-303. https://doi.org/10.1177/08853282261418176
56. Skopinska-Wisniewska, J., Tuszynska, M., Kazmierski, L., Bartniak, M., & Bajek, A. (2024). Gelatin-Sodium Alginate Hydrogels Cross-Linked by Squaric Acid and Dialdehyde Starch as a Potential Bio-Ink. Polymers, 16(18), 2560. https://doi.org/10.3390/POLYM16182560
57. Sullivan, T. P., Eaglstein, W. H., Davis, S. C., & Mertz, P. (2001). The pig as a model for human wound healing. Wound Repair and Regeneration, 9(2), 66-76. https://doi.org/10.1046/j.1524-475x.2001.00066.x
58. Tao, G., Cai, R., Wang, Y., Zuo, H., & He, H. (2021). Fabrication of antibacterial sericin based hydrogel as an injectable and mouldable wound dressing. Materials Science and Engineering C, 119. https://doi.org/10.1016/j.msec.2020.111597
59. Tranquilan-Aranilla, C., Barba, B. J., Relleve, L., Estacio, M. A., & Abad, L. (2021). Hemostatic efficacy evaluation of radiation-crosslinked carboxymethyl cellulose granules and kappa-carrageenan/polyethylene oxide/polyethylene glycol dressing in rat bleeding models. Journal of Biomaterials Applications, 35(9), 1143-1152. https://doi.org/10.1177/0885328220968395
60. Tyliszczak, B., Drabczyk, A., Kudlacik-Kramarczyk, S., Rudnicka, K., Gatkowska, J., Sobczak-Kupiec, A., & Jampilek, J. (2019). In vitro biosafety of pro-ecological chitosan-based hydrogels modified with natural substances. Journal of Biomedical Materials Research - Part A, 107(11), 2501-2511. https://doi.org/10.1002/jbm.a.36756
61. Ulu, A., Birhanli, E., Koytepe, S., & Ates, B. (2020). Chitosan/polypropylene glycol hydrogel composite film designed with TiO2 nanoparticles: A promising scaffold of biomedical applications. International Journal of Biological Macromolecules, 163, 529-540. https://doi.org/10.1016/j.ijbiomac.2020.07.015
62. Wang, C., Makvandi, P., Zare, E. N., Tay, F. R., & Niu, L. (2020a). Advances in Antimicrobial Organic and Inorganic Nanocompounds in Biomedicine. Advanced Therapeutics, 3(8), 2000024. https://doi.org/10.1002/adtp.202000024
63. Wang, L., Yang, K., Li, X., Zhang, X., Zhang, D., Wang, L. N., & Lee, C. S. (2021). A double-crosslinked self-healing antibacterial hydrogel with enhanced mechanical performance for wound treatment. Acta Biomaterialia, 124, 139-152. https://doi.org/10.1016/j.actbio.2021.01.038
64. Wang, S., Wang, X., Neufurth, M., Tolba, E., Schepler, H., Xiao, S., Schroder, H. C., & Muller, W. E. G. (2020b). Biomimetic Alginate/Gelatin Cross-Linked Hydrogels Supplemented with Polyphosphate for Wound Healing Applications. Molecules, 25(21), 5210. https://doi.org/10.3390/MOLECULES25215210
65. Yamaguchi, Y., & Yoshikawa, K. (2001). Cutaneous Wound Healing: An Update. The Journal of Dermatology, 28(10), 521-534. https://doi.org/10.1111/j.1346-8138.2001.tb00025.x
66. Zhang, M., Yang, M., Woo, M. W., Li, Y., Han, W., & Dang, X. (2021). High-mechanical strength carboxymethyl chitosan-based hydrogel film for antibacterial wound dressing. Carbohydrate Polymers, 256. https://doi.org/10.1016/j.carbpol.2020.117590
67. Zhang, N., Gao, T., Wang, Y., Liu, J., Zhang, J., Yao, R., & Wu, F. (2020). Modulating cationicity of chitosan hydrogel to prevent hypertrophic scar formation during wound healing. International Journal of Biological Macromolecules, 154, 835-843. https://doi.org/10.1016/j.ijbiomac.2020.03.161
68. Zou, Z., Wang, L., Zhou, Z., Sun, Q., Liu, D., Chen, Y., ... & Zou, X. (2021). Simultaneous incorporation of PTH (1-34) and nano-hydroxyapatite into Chitosan/Alginate Hydrogels for efficient bone regeneration. Bioactive materials, 6(6), 1839-1851.