Trametes Versicolor Biyokütlesi İle Reaktif Red 198 Boyarmaddesinin Biyosorpsiyonu

Year 2009, Volume: 22 Issue: 2, 247 - 264, 31.12.2009

Gökhan Güngörmedi Samet Şaşmaz Pınar Aytar Serap Gedikli Arzu Ünal Ahmet Çabuk , Nazif Kolankaya

Abstract

Tekstil endüstrisinde kullanılan büyük miktarda boyarmadde üretim sonunda doğal yaşam ortamına deşarj edilmekte bu da çevre ve insan sağlığı ile ilgili tehlikeler meydana getirmektedir. Bu boyarmaddelerin sebep olduğu kirliliğin biyolojik yöntemlerle azaltılması mümkündür. Bu çalışmada, Reaktif Red 198 boyarmaddesinin Trametes versicolor ATCC 200801’in kuru biyokütlesi ile biyosorpsiyonu çalışılmış ve en uygun koşullar belirlenmiştir. Yapılan çalışma sonucunda pH 2,0, biyokütle miktarı 0,4 g, başlangıç boyarmadde konsantrasyonu 75 mg/l, temas süresi 20 dk, çalkalama hızı 100 r.p.m., sıcaklık 35°C olarak seçilmiştir. Optimum koşullarda en yüksek %92,57 verim elde edilmiştir. Ayrıca yapılan FTIR analizleri ile T. versicolor fungal biyokütlesinin sahip olduğu ve Reaktif Red 198 biyosorpsiyonunda etkili olabilecek fonksiyonel gruplar belirlenmiştir.

Keywords

Reaktif Red 198, Trametes versicolor, boyarmadde, biyosorpsiyon

Biosorption Of Dyestuff Reactive Red 198 With Biomass Of Trametes Versicolor

Abstract

Large quantities of dyes used in the textile industry are discharged to natural life

at the end of manufacturing and processing operations which turn out much hazard related to

environment and human health. Pollution causing these dyestuffs is possible to reduce with

biological methods. In this work, biosorption of Reactive Red 198 dyestuff is studied with dry

biomasses of Trametes versicolor ATCC 200801 and optimum conditions are determined. At

result of study done, it is chosen pH 2,0, biomass amount 0,4 g, initial dye concentration 75

mg/l, contact time 20 minutes, agitation rate 100 r.p.m, temperature 35°C. Maximum yield

92,57% is acquired at optimum conditions. Also, potential functional groups of T.versicolor

biomass and efficient at biosorption of Reactive Red 198 were determined with FTIR analysis.

Keywords

Reactive Red 198, Trametes versicolor, dyestuff, biosorption.

References

• [1] P.C. Vandevivere, R. Bianchi, W. Verstraete, “Treatment and reuse of wastewater from the textile wet-processing industry:review of emerging tecnologies”, J.Chem. Technol. Biotechnol.,72, pp.9-302, 1998.
• [2] E.Y. Özmen, S. Erdemir, M. Yılmaz, et. al., “Removal of carcinogenic direct azo dyes from aqueous solutions using calix[n]arene derivatives”, Clean., 35, pp. 612-616, 2007.
• [3] Z. Aksu, Ş.Ş. Çağatay, “Investigation of biosorption of Gemazol Turquise Blue-G reactive dye by dried Rhizopus arrhizus in batch and continuous systems”, Sep. Purif. Technol., 48, 1, pp. 24-35, 2006.
• [4] K.V. Kumar, V. Ramamurthi and S. Sivanesan, “Biosorption of malachite green, a cationic dye onto Pithophora sp. a fresh water algae”, Dyes Pigments, pp. 69:74-79, 2006.
• [5] O.J. Hao, H. Kim, P.C. Chiang, “Decolorization of wastewater”, Crit. Rev. Environ. Sci. Technol., 30, pp. 449-505, 2000.
• [6] Z. Aksu, Ş.Ç. Çağatay, F. Gönen, “Continuous fixed bed biosorbtion of reactive dyes by dried Rhizopus arrhizus: determination of column capacity”, J. Hazard. Mater., 143, pp. 362-371, 2007.
• [7] H. Lata, V.K. Garg, R.K. Gupta, “Removal of a basic dye from aqueous solution by adsorption using Parthenium hysterophorus: an agricultural waste”, Dyes Pigments, 74, pp. 653-658, 2007.
• [8] I. Kiran, T. Akar, A. Safa Ozcan, et. al., “Biosorption kinetics and isotherm studies of Acid Red 57 by dried Cephalosporium aphidicola cells from aqueous solutions”, Biochem.Eng.J., 31, pp. 197-203, 2006.
• [9] R. Gong, Y. Ding, M. Li, et. al., “Utilization of powdered peanut hull as biosorbent for removal of anionic dyes from aqueous solution”, Dyes Pigments, 64, pp. 187-192, 2005.
• [10] T. Robinson, B. Chandran, P. Nigam, “Removal of dyes from a synthetic textile dye effluent by biosorption on apple pomace and wheat straw”, Water Res., 36, pp. 2824-2830, 2002.
• [11] Q. Husain, “Potential applications of the oxidoreductive enzymes in the decolorization and detoxification of textile and other synthetic dyes”, Critical Reviews in Biotechnology, 26, pp. 201-221, 2006.
• [12] T. Robinson, G. McMullan, R. Marchant, et. al., “Remediation of dyes in textile effluent: a critical review on current treatment Technologies with a proposed alternative”, Bioresour. Technol., 77, pp. 247-255, 2001.
• [13] B. Volesky, S. Schiewer, “Biosorption of metals, in: M. Flickinger, S.W.Drew(Eds.), Encyclopedia of Bioprocess Technology”, Wiley, New York, 433-453,1999.
• [14] S. Tunalı, A. Özcan, Z. Kaynak, et. al., “Utilization of the Phaseoulus vulgaris L. waste biomass for decolorization of the textile dye Acid Red 57: determination of equilibrium, kinetic and thermodynamic parameters”, J. Environ.Sci.Health A, 42, pp. 591-600, 2007.
• [15]C. Namasivayam, N. Muniasamy, K. Gayatri, et. al., “Removal of dyes from aqueous solutions by cellulosic waste orange peel”, Bioresour. Technol., 57, pp. 37–43, 1996.
• [16] G. McKay, J.F. Porter, G.R. Prasad, “The removal of dye colours from aqueous solutions by sorption on low-cost materials”, Water Air Soil Pollut., 114, pp. 423–438, 1999.
• [17] B.S. Inbaraj, N. Sulochana, “Basic dye sorption on a low cost carbonaceous sorbent: kinetic and equilibrium studies”, Indian J. Chem. Technol., 9, pp. 201–208, 2002.
• [18] T.L. Hu, “Removal of reactive dyes from aqueous solution by different bacterial genera”, Water Sci. Technol., 34, pp. 89– 95, 1996.
• [19] Z. Aksu, S. Tezer, “Biosorption of reactive dyes on the green alga Chlorella vulgaris”, Process Biochem., 40, pp. 1347–1361, 2005.
• [20] T.O. O’Mahony, E. Guibal, J.M. Tobin, “Reactive dye biosorption by Rhizopus arrhizus biomass”, Enzyme Microb. Technol., 31, pp. 456-463, 2002.
• [21] H.G. Kulla, F. Klausener, U. Meyer, et. al., “Interference of aromatic sulfo groups in the microbial degradation of azo dyes Orange I and Orange II”, Arch. Microbial., 135, pp. 1-7, 1983.
• [22] I.M. Banat, P. Nigam, R.M. Singh, “Microbial decolourization of textile dyes containing effluents: a review”, Bioresour Technol., 58, pp. 217-27, 1996.
• [23] N.S. Maurya, A.K. Mittal, P. Cornel, et. al., “Biosorption of dyes using dead macro-fungi: effect of dye structure, ionic strength and pH”, Bioresour. Technol., 97, pp. 512-521, 2006.
• [24] J.T. Matheickal, Q. Yu, “Biosorption of lead (II) from aqueous solutions by Phellinus badius”, Miner. Eng., 10, pp. 947-957, 1997.
• [25] D. Wesenberg, I. Kyriakides, SN. Agathos, “White-rot fungi and their enzymes for the treatment of industrial dye effluents”, Biotechnol. Adv., 22, pp. 161-187, 2003.
• [26] N. Aktaş, , H. Çiçek, , A. Ünal, , et. al., “Reaction kinetics for laccase-catalyzed polymerization of 1-naphthol”, Bioresource Technol., 80, 1, pp. 29-36, 2001.
• [27] S. Tunali, T. Akar, A. Cabuk, “Decolorization of a textile dye, Reactive Red 198 (RR198), by Aspergillus parasiticus fungal biosorbent”, Brazilian Journal of Chemical Engineering, 26, 2, pp. 399-405, 2009.
• [28] S.T. Akar, A. Görgülü, Z. Kaynak, et. al., “Biosorption Reactive Blue 49 dye under batch and continuous mode using a mixed biosorbent of macro-fungus Agaricus bioporus and Thuja orientalis cones”, Chemical Engineering Journal, 148, pp. 26-34, 2009a.
• [29] F. Çolak, N. Atar, A. Olgun, “Biosorption of acidic dyes from aqueous solution by Paenibacillus macerans: Kinetic, thermodynamic and equilibrium studies”, Chemical Engineering Journal, 150, pp. 122-130, 2009.
• [30] M.S. Chiou, G.S. Chuang, “Competetive adsorbtion of dye metanil yellow and RB15 in acidic solutions on chemically cross-linked chitosan beads”, Chemosphere, 62, pp. 731- 740, 2006.
• [31] Z. Aksu, “Reactive dye bioaccumulation by Saccharomyces cerevisae”, Process Biochem., 38, pp. 1437 – 1444, 2003.
• [32] D.K. Bakshi, K.G. Gupta, P. Sharma, “Enhanged biodecolorization of synthetic textile dye effluent by Phanerochaete chrysosporium under improved culture conditions”, World J. Microbiol. Biotechnol., 15, pp. 507-509, 1999.
• [33] T. Akar, B. Anılan, A. Görgülü, S.T. Akar, “Assessment of cationic dye biosorption characteristics of untreated and non-conventional biomass: Pyracantha coccinea berries”, Journal of Hazardous Materials, 168, pp. 1302-1309, 2009b.
• [34] Z. Zhang, S. Xia, X. Wang,et. al., “A novel biosorbent for dye removal: Extracellular polymeric substance (EPS) of Proteus mirabilis TJ-1”, Journal of Hazardous Materials, 163, pp. 279–284, 2009.
• [35] A. Özer, D. Özer, H.I. Ekiz, “Application of Freundlich and Langmuir models to multistage purification process to remove heavymetal ions by using Schizomeris leibleinii”, Process Biochem., 34, pp. 919–927, 1999.
• [36] G. Dönmez, Z. Aksu, “Removal of chromium (VI) from saline wastewaters by Dunaliella species”, Process Biochem., 38, pp. 751–762, 2002.
• [37] A. Shukla, Y. Zhang, P. Dubey, et. al., “The role of sawdust in the removal of unwanted materials from water”, J. Hazard. Mater., 95, pp. 137–152, 2002.