Aromatik hidrokarbonların dedekte edilmesi için kaliksaren bazlı diamid kimyasal sensor çiplerinin geliştirilmesi

Yıl 2021, Cilt: 23 Sayı: 1, 291 - 300, 29.01.2021

Nursel Zeybek Yaser Açıkbaş Selahattin Bozkurt Abdulkadir Sirit Rifat Çapan Matem Erdoğan Cansu Özkaya

https://doi.org/10.25092/baunfbed.850859

Cited By: 1

Öz

Sunulan çalışmada, yeni kaliks[4]aren bazlı diamid makrosiklik malzemesi (SB77) sensör malzemesi olarak seçildi ve bu makrosiklik bileşiklerin Langmuir-Blodgett (LB) ince filmlerinin, aromatik hidrokarbon (benzen, toluen, ksilen)buharlarına karşı buhar algılama kapasiteleri Kuartz Kristal Mikrobalans (KKM) tekniği ile araştırılmıştır. Belirtilen amaç ile uyumlu olarak, kaliks[4]aren LB ince filmler kuartz kristal yüzeyler üzerinde hazırlanmıştır. SB77 LB ince filmlerin karakterizasyonu kuartz kristal yüzey üzerine üretilmiş 9 LB tabaka için gerçekleştirilmiştir. Bu LB ince filmlerin her bir tabaka için frekans değişimleri ve kütle miktarı değişimi sırasıyla 32.35 Hz / tabaka and 2206.65 ng (8.32 ng mm-2) olarak elde edilmiştir. Bütün QCM sonuçları, SB77 LB ince film kimyasal sensörlerin benzer buharının doymuş ve farklı konsantrasyonlarda diğer aromatik hidrokarbon buharlarına göre yüksek tepki, iyi bir hassasiyetlik ve seçicilik sergilediğini göstermiştir.SB77 kaliks[4]aren makrosiklik malzemesi, oda sıcaklığında basit ve düşük maliyet ile hazırlanması ile organik buhar dedekte etme uygulamaları için potansiyel aday olmaya sahiptir.

Anahtar Kelimeler

Kaliksaren bazlı diamid, LB ince film, kimyasal sensör, KKM

Developing of the calixarene based diamide chemical sensor chip for detection of aromatic hydrocarbons’ vapors

Öz

In the present work, a new macrocycle materials (SB77) was selected and Langmuir-Blodgett thin films of this macrocycle compounds were examined for its vapor sensing capabilities against vapor of aromatic BTX hydrocarbons (benzene, toluene, xylene) through Quartz Crystal Microbalance (QCM) technique. In accordance with this aim, the calix[4]arene LB thin films were prepared onto quartz crystal substrates. The characterization of SB77 LB thin film was performed for nine LB layers fabricated onto the quartz crystal. The frequency shifts and the mass changes for monolayer of these LB thin films were obtained as 32.35 Hz / per layer and 2206.65 ng (8.32 ng mm-2), respectively. All QCM results indicated that SB77 LB thin film chemical sensors exhibits high response, a good sensitivity and selectivity for benzene vapor at saturated or different concentrations than other aromatic hydrocarbon vapors. These LB thin film sensors with SB77 calix [4]arene macrocycle materials have been potential candidates for organic vapor sensing applications with simple and low cost preparation at room temperature.

Anahtar Kelimeler

Calixarene based diamide, LB thin film, chemical sensor, QCM

Kaynakça

• Hamdi, K., Martin, P., Etienne, M., and Hébrant, M., Rapid and reversible adsorption of BTX on mesoporous silica thin films for their real time spectrophotometric detection in air at ppm levels, Talanta, 203, 269-273, (2019).
• Choudhury, S.P., Feng, Z., Gao, C., Ma, X., Zhan, J., and Jia, F., BN quantum dots decorated ZnO nanoplates sensor for enhanced detection of BTEX gases, Journal of Alloys and Compounds, 815,152-376, (2020).
• Bearzotti, A., Macagnano, A., P. Papa, Venditti, I., and Zampetti, E., A study of a QCM sensor based on pentacene for the detection of BTX vapors in air, Sensors and Actuators B-Chemical, 240, 1160-1164, (2017).
• Singhal, P., Mazumdar, P., and Rattan, S., One pot synthesis of free standing highly conductive polymer nanocomposite films: Towards rapid BTX vapor sensor, Polymer Engineering and Science, 58, 1074-1081, (2018).
• Zhang, Y.H., Liu, C. Y., Jiu, B.B., Liu, Y., and Gong, F.L., Facile synthesis of Pd-decorated ZnO nanoparticles for acetone sensors with enhanced performance. Research on Chemical Intermediates, 44, 1569-1578, (2018).
• Kolthoff, I. M., Application of macrocyclic compounds in chemical analysis, Analytical Chemistry, 51(5), 1-22, (1979).
• Pinalli, R., Pedrini, A., and Dalcanale, E., Biochemical sensing with macrocyclic receptors, Chemical Society Reviews, 47, 7006-7026, (2018).
• Gorbatchuk, V. V., Tsifarkin, A. G., Antipin, I. S., Solomonov, B. N., and Konovalov, A. I., Influence of the guest molecular size on the thermodynamic parameters of host–guest complexes between solid tert-butylcalix[4]arene and vapours of organic compounds, Mendeleev Communications, 9(1), 11-13, (1999).
• Acikbas, Y., Bozkurt, S., Erdogan, M., Halay, E., Sirit, A., Capan, R., Optical and Vapor Sensing Properties of Calix[4]arene Langmuir-Blodgett Thin Films with Host–Guest Principles, Journal of Macromolecular Science Part A-Pure and Applied Chemistry, 55(7), 526-532, (2018).
• Sekiya, R., Yamasaki, Y., Tada, W., Shio, H., and Haino, T., Guest induced head-to-tail columnar assembly of 5,17-difunctionalized calix[4]arene, Crystal Engineering Communication, 16, 6023-6032, (2014).
• Capan, I., Bayrakci, M., Erdogan, M., and Ozmen, M., Fabrication of Thin Films of Phosphonated Calix[4]Arene Bearing Crown Ether and Their Gas Sensing Properties, IEEE Sensors Journal, 19(3), 838-845, (2019).
• Dermody, L., Lee, Y., Kim, T., and Crooks, R.M., Synthesis, Characterization, and Chemical Sensitivity of Self-Assembled Bilayers Composed of Polydiacetylenes and Calix[4]arenes Chemically Modified on the Upper Rim, Langmuir, 15, 8435-8440, (1999).
• Ozbek, Z., Çapan, R., Goktaş, H., Şen, S., İnce, F.G., Ozel, M.E., and Davis, F., Optical parameters of calix[4]arene films and their response to volatile organic vapors, Sensors and Actuators B-Chemical, 158, 235-240, (2011).
• Bozkurt, S., Yılmaz, M., and Sirit, A., Chiral calix[4]arenes bearing amino alcohol functionality as membrane carriers for transport of chiral amino acid methylesters and mandelic acid, Chirality, 24, 129-136, (2012).
• Halay, E., Acikbas, Y., Capan, R., Bozkurt, S., Erdogan, M., and Unal, R., A novel triazine‒bearing calix [4] arene: Design, synthesis and gas sensing affinity for volatile organic compounds, Tetrahedron, 75, 2521-2528, (2019).
• Acikbas, Y., Dogan, G., Erdogan, M., Capan, R., Soykan, C., Organic vapor sensing properties of copolymer Langmuir-Blodgett thin film sensors, Journal of Macromolecular Science Part A-Pure and Applied Chemistry, 53, 470-474, (2016).
• Acikbas, Y., Capan, R., Erdogan, M., and Yukruk, F., Characterization and organic vapor sensing properties of Langmuir-Blodgett film using perylendiimide material, Journal of Research on Engineering Structures and Materials, 2, 99-106, (2015).
• Kursunlu, A.N., Acikbas, Y., Ozmen,M., Erdogan, M., and Capan, R., Haloalkanes and aromatic hydrocarbons sensing using Langmuir–Blodgett thin film of pillar[5]arene-biphenylcarboxylic acid, Colloids and Surfaces A: Physicochemical and Engineering Aspects, 565, 108-117, (2019).