HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ

Yakup Sekmen; Sedat Şen

doi:10.17341/gummfd.41080

HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ

Öz

Petrol kaynaklarının sınırlı olması, çevre ile ilgili endişeler, atık ürünlerin değerlendirilmesi ve kirletici emisyonlara getirilen sınırlamalar alternatif yakıt olan biyodizele olan ilgiyi artırmaktadır. Biyodizel, bitkisel, hayvansal ve atık yağlardan üretilebilen; oksijen içerikli, sülfür içermeyen, zehirleyici olmayan, bozunabilir, yüksek setan sayılı ve yağlayıcılık özelliği daha iyi yenilenebilir alternatif bir dizel yakıtıdır. Bu çalışmada, hamsi yağından üretilmiş biyodizel ve dizel yakıtı ile karışımlarının (hacimsel olarak %5, 20, 50 ve 100), dört zamanlı, tek silindirli bir dizel motorda performans ve egzoz emisyonlarına etkileri tam yük ve değişik devirlerde test edilmiştir. Deneyler sonucunda, karışımdaki biyodizel oranı arttıkça dizel yakıta göre özgül yakıt tüketiminde %5-12 artış, motor momentinde ise %2-6 azalma belirlenmiştir. Emisyon testleri sonucunda, CO, HC ve is emisyonlarında azalma, NO_x emisyonlarında artış belirlenmiştir.

Anahtar Kelimeler

Balık yağı,hamsi yağı,biyodizel,dizel motor,egzoz emisyonları

Kaynakça

Keskin, A., Gürü, M., Altıparmak, D., “Influence of tall oil biodiesel with Mg and Mo based fuel additives on diesel engine performance and emission”, Bioresource Technology, Cilt 99, 6434–6438, 2008.
Çelikten İ., Gürü M., “Improvement of performance and emission criterias of petrodiesel and rapeseed oil biodiesel with manganese based additive”, Journal of the Faculty of Engineering and Architecture of Gazi University, Cilt 26, No 3, 643-648, 2011.
Gürü, M., Artukoğlu, B.D., Keskin, A., Koca, A., “Biodiesel production from waste animal fat and improvement of its characteristics by synthesized nickel and magnesium additive”, Energy Conversion and Management, Cilt 50, 498-502, 2009.
Yahyaee, R., Ghobadian, B., Najafi, G., “Waste fish oil biodiesel as a source of renewable fuel in Iran”, Renewable and Sustainable Energy Reviews, Cilt 17, 312-319, 2013.
Gürü, M., Koca, A., Can, Ö., Çınar, C., Şahin, F., “Biodiesel production from waste chicken fat based sources and evaluation with mg based additive in a diesel engine”, Renewable Energy, Cilt 35, No 3, 637-643, 2010.
Sekmen, Y., “Use of watermelon and flax seed oil methyl esters as a fuel in a diesel engine”, Technology, Cilt 10, No 4, 295-302, 2007.
Sekmen, Y., Aktaş, A., ‘‘Effects of soybean oil methyl ester on diesel engine performance and exhaust emissions’’ Journal of Polytechnic, Cilt 11, No 3, 249-254, 2008.
Çengelci, E., Bayrakçeken, H., Aksoy, F., “Effect of animal fat methyl ester usage on engine performance and emissions in a diesel engine”, 6th International Advanced Technologies Symposium (IATS’11), Elazığ, 113-116, 2011.

Aktaş, A., Sekmen, Y., “The effects of advance fuel injection on engine performance and exhaust emissions of a diesel engine fuelled with biodiesel”, Journal of the Faculty of Engineering and Architecture of Gazi University, Cilt 23, No 1, 199-206, 2008.
Canakci, M., “Combustion characteristics of a turbocharged DI compression ignition engine fueled with petroleum diesel fuels and biodiesel”, Bioresource Technology, Cilt 98, 1167-1175, 2007.
Behçet, R., Çakmak, A.V., “Effect of fish oil methyl ester blends on engine performance and emissions in a diesel engine”, 6th International Advanced Technologies Symposium (IATS’11), Elazığ, 161-165, 16-18 May, 2011.
Zhang, J., Chen, S., Yang, R. Yan, Y., “Biodiesel production from vegetable oil using heterogenous acid and alkali catalyst”, Fuel, Cilt 89, 2939-2944, 2010.
Yücesu, H.S., Altın, R., Çetinkaya, S., “Experimental investigation of vegetable oil usage as alternative fuel in diesel engine”, Turk J Engin Environ Sci, Cilt 25, 39-49, 2001.
No, S.Y., “Inedible vegetable oils and their derivatives for alternative diesel fuels in CI engines”, Renewable and Sustainable Energy Reviews, Cilt 15, 131-149, 2011.
Aziz AA., Said, MF., Awang, MA., “Performance of palm oil- based biodiesel fuels in a single cylinder direct injection engine”, Malaysian Palm Oil Development, Cilt 42, 15-27, 2005.
Monyem, A., Van Gerpen, JH., “The effect of biodiesel oxidation on engine performance and emissions”, Biomass and Bioenergy, Cilt 20, 317-325, 2001.
Fernando, S., Hall C., Jha, S., “NOx reduction from biodiesel fuels”, Energy and Fuels, Cilt 20, 376-382, 2006.
Kegl B., “Experimental investigation of optimal timing of the diesel engine injection pump using biodiesel”, Energy and Fuels, Cilt 20, 1460-1470, 2006.
Dorado, MP., Ballesteros E., Arnal, JM., Gomez, J., Lopez, FJ., “Exhaust emissions from a diesel engine fuelled with transesterified waste olive oil”, Fuel, Cilt 82, No 11, 1311-1315, 2003.
Kalam, MA., Masjuki, HH., “Biodiesel from palm oil an analysis of its properties and potential”, Biomass Bioenergy, Cilt 23, 471-479, 2002.
Lin, CY., Huang, JC., “An oxygenating additive for improving the performance and emission characteristics of marine diesel engines”, Ocean Engineering, Cilt 30, 1699-1715, 2003.
Buyukkaya, E., Benli, S., Karaaslan, S., Guru, M., “Effects of trout-oil methyl ester on diesel engine performance and emission characteristics”, Energy Conversion and Management, Cilt 69, 41-48, 2013.
Şen, S., “Biodiesel production from animal fats and investigating their effect on diesel engine performance and emissions”, M. Sc. Thesis, Karabuk University, Graduate School of Natural and Applied Sciences, 2012.
Reyes, J.F., Sepülveda, M.A., “Pm-10 emissions and power of a diesel engine fueled with crude and refined biodiesel from salmon oil”, Fuel, Cilt 85, 12-13, 1714–1719, 2006.
Godiganur, S., Murthy, C.S., Reddy, R.P., “Performance and emission characteristics of a Kirloskar HA394 diesel engine operated on fish oil methyl esters”, Renewable Energy, Cilt 35, No 2, 355–359, 2010.
Akçay, M., Sekmen, Y., Yılmaz, İT., Gölcü, M., Yazıcı, H., “The place of free fatty acids and water in biodiesel production process from waste oils,” International Scientific Conference (UNITECH’10), Gabrova, Bulgaria, 574-578, 19-20 November 2010.
Canakcı M., The potential of restaurant waste lipids as biodiesel feedstocks, Bioresource Technology, Cilt 98, 183-190, 2007.
Ramadhas AS., Jayaraj S., Muraleedharan C., Biodiesel production from high FFA rubber seed oil, Fuel, Cilt 84, 335-340, 2005.
Van Gerpen J., Biodiesel processing and production, Fuel Processing Technology, Cilt 86, 1097-1107, 2005.
Echim, C., Maes, J., Greyt, WD., “Improvement of cold filter plugging point of biodiesel from alternative feedstocks”, Fuel, Cilt 93, 642–8, 2012.
Usta, N., Aydogan, B., Con AH., Uguzdogan, E., Ozkal, SG., “Properties and quality verification of biodiesel produced from tobacco seed oil”, Energy Conversion and Management, Cilt 52, No 5, 2031–9, 2011.
Olgunoğlu, İ.A., “Sensory chemical and microbiological changes of marinated anchovy (Engraulis engrasicholus L., 1758)”, PhD. Thesis, University of Cukurova, Institute of Natural and Applied Sciences, 2007.
Gökoğlu, N. , Özden Ö., Erkan, N., Taçnur T., Metin, B., Metin, S., “Seasonal variation in fat content of anchovy (Engraulis encrasicolus)”, International Journal of Food Science and Technology, Cilt 34, 401–402, 1999.
Özden, Ö., “Changes in amino acid and fatty acid composition during shelf-life of marinated fish”, Journal of the Science of Food and Agriculture, Cilt 85, 2015-2020, 2005.
Cascado, S.P.S., Vıdal-Carou, M.C., Nunes, M.L., “Vecıananogués, M.T., Sensory analysis to assess the frehness of Mediterranean anchovies (Engraulis encrasicholus) stored in ice”, Food Control, Cilt 17, 564-569, 2006.
TÜİK su ürünleri istatistikleri, 2011. http://www.tuik.gov.tr/PreHaberBultenleri.do?id=10863, 29.05.2013.
Ghazali, W.N.M.W., Mamat, R., Masjuki, H.H., Najafi, G., “Effects of biodiesel from different feedstocks on engine performance and emissions: A review”, Renewable and Sustainable Energy Reviews, Cilt 51, 585–602, 2015.
Usta N., “An experimental study on performance and exhaust emissions of a Diesel engine fuelled with tobacco seed oil methyl ester”, Energy Conversion and Management, Cilt 46, No 15-16, 2373–86, 2005.
Özcanlı, M., Keskin, A., Aydın, K., “Biodiesel production from terebinth (pistacia terebinthus) oil and its usage in diesel engine”, International Journal of Green Energy, Cilt 8, No 5, 518–528, 2011.
Abdel-Rahman, AA., “On the emissions from internal-combustion engines: a review”, International Journal of Energy Research, Cilt 22, No 6, 483-513, 1998.
Kumar, MS., Kerihuel, A., Belletre, J., Tazerout, M., “Experimental investigations on the use of preheated animal fat as fuel in a compression ignition engine”, Renewable Energy, Cilt 30, No 1, 1445-1456, 2005.
Usta, N., Öztürk, E., Can, Ö., Conkur, ES., Nas, S., Çon, AH., Can, AÇ., Topcu, M., “Combustion of biodiesel fuel produced from hazelnut soapstock/waste sunflower oil mixture in a Diesel engine”, Energy Conversion and Management, Cilt 46, No 5, 741-755, 2005.
Özsezen, AN., Çanakçi, M., Turkcan, A., Sayin, C., “Performance and combustion characteristics of a DI diesel engine fueled with waste palm oil and canola oil methyl esters”, Fuel, Cilt 88, No 4, 629–636, 2009.

Ayrıntılar

Birincil Dil

Türkçe

Konular

-

Bölüm

-

Yazarlar

Yakup Sekmen

Sedat Şen

Yayımlanma Tarihi

17 Aralık 2016

Gönderilme Tarihi

23 Mart 2016

Kabul Tarihi

-

Yayımlandığı Sayı

Yıl 2016 Cilt: 31 Sayı: 1

DOI

https://doi.org/10.17341/gummfd.41080

IZ

https://izlik.org/JA85SZ47TR

Kaynak Göster

RIS / Bibtex

APA

Sekmen, Y., & Şen, S. (2016). HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ. Gazi Üniversitesi Mühendislik Mimarlık Fakültesi Dergisi, 31(1). https://doi.org/10.17341/gummfd.41080

AMA

1.Sekmen Y, Şen S. HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ. GUMMFD. 2016;31(1). doi:10.17341/gummfd.41080

Chicago

Sekmen, Yakup, ve Sedat Şen. 2016. “HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ”. Gazi Üniversitesi Mühendislik Mimarlık Fakültesi Dergisi 31 (1). https://doi.org/10.17341/gummfd.41080.

EndNote

Sekmen Y, Şen S (01 Mart 2016) HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ. Gazi Üniversitesi Mühendislik Mimarlık Fakültesi Dergisi 31 1

IEEE

[1]Y. Sekmen ve S. Şen, “HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ”, GUMMFD, c. 31, sy 1, Mar. 2016, doi: 10.17341/gummfd.41080.

ISNAD

Sekmen, Yakup - Şen, Sedat. “HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ”. Gazi Üniversitesi Mühendislik Mimarlık Fakültesi Dergisi 31/1 (01 Mart 2016). https://doi.org/10.17341/gummfd.41080.

JAMA

1.Sekmen Y, Şen S. HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ. GUMMFD. 2016;31. doi:10.17341/gummfd.41080.

MLA

Sekmen, Yakup, ve Sedat Şen. “HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ”. Gazi Üniversitesi Mühendislik Mimarlık Fakültesi Dergisi, c. 31, sy 1, Mart 2016, doi:10.17341/gummfd.41080.

Vancouver

1.Yakup Sekmen, Sedat Şen. HAMSİ (Engraulis encrasicolus) YAĞINDAN BİYODİZEL ÜRETİMİ VE DİZEL MOTOR PERFORMANS VE EMİSYONLARINA ETKİSİ. GUMMFD. 01 Mart 2016;31(1). doi:10.17341/gummfd.41080

Cited By

pamuk yağı metil esteri-eurodizel yakıt karışımlarının direkt püskürtmeli bir dizel motorunun yanma, performans ve emisyon karakteristiklerine etkisi

Gazi Üniversitesi Mühendislik-Mimarlık Fakültesi Dergisi

https://doi.org/10.17341/gazimmfd.460490

BİYO-YAĞ ÜRETİMİ İÇİN MİKROALGİN METAL HALOJENÜRLER İLE HİDROTERMAL SIVILAŞTIRILMASI

Gazi Üniversitesi Mühendislik-Mimarlık Fakültesi Dergisi

https://doi.org/10.17341/gazimmfd.460484

DENİZEL EKOSİSTEM ÜZERİNE OLUMSUZ ETKİSİ OLAN BİTKİSEL ATIK YAĞLARIN BİYODİZEL OLARAK GERİ KAZANIMI

Soma Meslek Yüksekokulu Teknik Bilimler Dergisi

https://doi.org/10.47118/somatbd.894337