A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point

Fırat Aydemir; Mehmet Ebeoğlu

doi:10.5281/zenodo.4698418

TR EN

A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point

Öz

In this study, a driver system for high-power light-emitting diodes (LEDs) is presented. The proposed driver system is based on flyback converter topology, and it uses single-stage power factor correction with microcontroller support. The driver has two main parts; a source for an LED array, and a control unit including sensors. Instead of using conventional constant voltage or constant current driver topologies, the proposed system adjusts the output voltage by considering the LED parameters, the number of serial and parallel LEDs on the load array, and the data from sensors. Via the current sensor, the output current is measured at specific periods and limited by the microcontroller according to the LED load. Moreover, the microcontroller can detect an open circuit condition on the LED array by following current changes. A temperature sensor and a light-dependent resistor (LDR) are used to increase the lifetime of LEDs.

Anahtar Kelimeler

LED , LED Driver , Smart Driver , LED Life , LED Array

A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point

Abstract

In this study, a driver system for high-power light-emitting diodes (LEDs) is presented. The proposed driver system is based on flyback converter topology, and it uses single-stage power factor correction with microcontroller support. The driver has two main parts; a source for an LED array, and a control unit including sensors. Instead of using conventional constant voltage or constant current driver topologies, the proposed system adjusts the output voltage by considering the LED parameters, the number of serial and parallel LEDs on the load array, and the data from sensors. Via the current sensor, the output current is measured at specific periods and limited by the microcontroller according to the LED load. Moreover, the microcontroller can detect an open circuit condition on the LED array by following current changes. A temperature sensor and a light-dependent resistor (LDR) are used to increase the lifetime of LEDs.

Keywords

LED , LED Driver , Smart Driver , LED Life , LED Array

Kaynakça

[1]Y. Wang, J. M. Alonso and X. Ruan, "A Review of LED Drivers and Related Technologies," in IEEE Transactions on Industrial Electronics, vol. 64, no. 7, pp. 5754-5765, July 2017.
[2]M. R. Krames, O. B. Shchekin, R. Mueller-Mach, G. O. Mueller, L. Zhou, G. Harbers, and M. G. Craford, "Status and Future of High-Power Light-Emitting Diodes for Solid-State Lighting," Display Technology, Journal of, vol.3, no.2, pp.160,175, June 2007.
[3]Yan-Cun Li; Chen, Chern-Lin, "A Novel Single-Stage High-Power-Factor AC-to-DC LED Driving Circuit With Leakage Inductance Energy Recycling," IEEE Trans. Industrial Electronics, vol.59, no.2, pp.793,802, Feb. 2012.
[4]Moschopoulos, G.; Jain, P., "Single-phase single-stage power-factor-corrected converter topologies," IEEE Trans. Industrial Electronics, vol.52, no.1, pp.23 -35, Feb. 2005.
[5]J. Lee, J. Kwon, E. Kim, W. Choi and B. Kwon, "Single-Stage Single-Switch PFC Flyback Converter Using a Synchronous Rectifier," in IEEE Transactions on Industrial Electronics, vol. 55, no. 3, pp. 1352-1365, March 2008.
[6]Y. Wang, J. Huang, G. Shi, W. Wang and D. Xu, "A Single-Stage Single-Switch LED Driver Based on the Integrated SEPIC Circuit and Class-E Converter," in IEEE Transactions on Power Electronics, vol. 31, no. 8, pp. 5814-5824, Aug. 2016.
[7]B. Poorali and E. Adib, "Analysis of the Integrated SEPIC-Flyback Converter as a Single-Stage Single-Switch Power-Factor-Correction LED Driver," in IEEE Transactions on Industrial Electronics, vol. 63, no. 6, pp. 3562-3570, June 2016.
[8]X. Liu, Q. Yang, Q. Zhou, J. Xu and G. Zhou, "Single-Stage Single-Switch Four-Output Resonant LED Driver With High Power Factor and Passive Current Balancing," in IEEE Transactions on Power Electronics, vol. 32, no. 6, pp. 4566-4576, June 2017.
[9]B. Poorali, E. Adib and H. Farzanehfard, "A Single-Stage Single-Switch Soft-Switching Power-Factor-Correction LED Driver," in IEEE Transactions on Power Electronics, vol. 32, no. 10, pp. 7932-7940, Oct. 2017.
[10]C. Moo, Y. Chen, S. Member, and W. Yang, "An Efficient Driver for Dimmable LED Lighting," IEEE Trans. Power Electron., vol. 27, no. 11, pp. 4613–4618, 2012.

[11]S. Li, S. Tan, C. K. Lee, E. Waffenschmidt, S. Y. Hui and C. K. Tse, "A survey, classification, and critical review of light-emitting diode drivers," in IEEE Transactions on Power Electronics, vol. 31, no. 2, pp. 1503-1516, Feb. 2016.
[12]R. Zhang; H. Chung; "Transformer-Isolated Resonant Driver for Parallel Strings with Robust Balancing and Stabilization of Individual LED Current," IEEE Trans. Power Electron., vol.29, no.7, pp.3694-3708, Jul. 2014.
[13]S. N. Li, W. X. Zhong, W. Chen and S. Y. R. Hui, "Novel Self-Configurable Current-Mirror Techniques for Reducing Current Imbalance in Parallel Light-Emitting Diode (LED) Strings," in IEEE Transactions on Power Electronics, vol. 27, no. 4, pp. 2153-2162, April 2012.
[14]S. Li and S. Y. Ron Hui, "Self-Configurable Current-Mirror Circuit With Short-Circuit and Open-Circuit Fault Tolerance for Balancing Parallel Light-Emitting Diode (LED) String Currents," in IEEE Transactions on Power Electronics, vol. 29, no. 10, pp. 5498-5507, Oct. 2014.
[15]Y. Yu, F. Zhang and J. Ni, "Capacitor clamped current sharing circuit for multi-string LEDs," 2012 IEEE Energy Conversion Congress and Exposition (ECCE), Raleigh, NC, 2012, pp. 3568-3574.
[16]Y. Hu and M. M. Jovanovic, "LED Driver With Self-Adaptive Drive Voltage," in IEEE Transactions on Power Electronics, vol. 23, no. 6, pp. 3116-3125, Nov. 2008.
[17]X. Liu, Q. Yang, Q. Zhou, J. Xu and G. Zhou, "Single-Stage Single-Switch Four-Output Resonant LED Driver with High Power Factor and Passive Current Balancing," in IEEE Transactions on Power Electronics, vol. 32, no. 6, pp. 4566-4576, June 2017.
[18]J. Yeon, D. Kim, K. Cho, and H. Kim, "A single stage flyback power supply unit for LED lighting applications," Electrical and Electronics Engineering, 2009. ELECO 2009. International Conference on, vol., no., pp.I-288, I-292, 5-8 Nov. 2009.
[19]P. S. Almeida, V. C. Bender, H. A. C. Braga, M. A. Dalla Costa, T. B. Marchesan and J. M. Alonso, "Static and Dynamic Photoelectrothermal Modeling of LED Lamps Including Low-Frequency Current Ripple Effects," in IEEE Transactions on Power Electronics, vol. 30, no. 7, pp. 3841-3851, July 2015.
[20]Narendran, N.; Gu, Y., "Life of LED-based white light sources," Journal of Display Technology, vol.1, no.1, pp.167,171, Sept. 2005.
[21]Alliance for Solid-State Illumination Systems and Technologies (ASSIST), ASSIST Recommends: LED Life for General Lighting, Lighting Research Center, vol.1, no.1, February 2005.
[22]E.Fred Schubert, "Light-Emitting Diodes", pp. 104-107, Cambridge University Press, 2003.
[23]Garcia, J.; Dalla-Costa, M.A.; Cardesin, J.; Alonso, J.M.; Rico-Secades, M., "Dimming of High-Brightness LEDs by Means of Luminous Flux Thermal Estimation," IEEE Trans. Power Electron., vol.24, no.4, pp.1107-1114, April 2009.
[24]X. Perpiñà et al., "Thermal Analysis of LED Lamps for Optimal Driver Integration," in IEEE Transactions on Power Electronics, vol. 30, no. 7, pp. 3876-3891, July 2015.
[25]Gacio, D.; Alonso, J.M.; Garcia, J.; Campa, L.; Crespo, M.J.; Rico-Secades, M., "PWM Series Dimming for Slow-Dynamics HPF LED Drivers: The High-Frequency Approach," IEEE Trans. Industrial Electronics, vol.59, no.4, pp.1717,1727, April 2012.
[26]Fully Integrated, Hall Effect-Based Linear Current Sensor IC with 2.1 kVRMS Isolation and a Low-Resistance Current Conductor, Allegro microsystems, ACS712 product datasheet, rev.14, pp. 5-9, 2011.

Ayrıntılar

Birincil Dil

İngilizce

Konular

Elektrik Mühendisliği

Bölüm

Araştırma Makalesi

Yazarlar

Fırat Aydemir ^*
0000-0002-8965-1429
Türkiye

Mehmet Ebeoğlu
0000-0003-3045-3003
Türkiye

Yayımlanma Tarihi

21 Haziran 2021

Gönderilme Tarihi

10 Nisan 2021

Kabul Tarihi

17 Nisan 2021

Yayımlandığı Sayı

Yıl 2021 Cilt: 2 Sayı: 1

DOI

https://doi.org/10.5281/zenodo.4698418

IZ

https://izlik.org/JA58KY24KU

APA

Aydemir, F., & Ebeoğlu, M. (2021). A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point. Journal of Science, Technology and Engineering Research, 2(1), 23-31. https://doi.org/10.5281/zenodo.4698418

AMA

1.Aydemir F, Ebeoğlu M. A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point. Journal of Science, Technology and Engineering Research. 2021;2(1):23-31. doi:10.5281/zenodo.4698418

Chicago

Aydemir, Fırat, ve Mehmet Ebeoğlu. 2021. “A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point”. Journal of Science, Technology and Engineering Research 2 (1): 23-31. https://doi.org/10.5281/zenodo.4698418.

EndNote

Aydemir F, Ebeoğlu M (01 Haziran 2021) A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point. Journal of Science, Technology and Engineering Research 2 1 23–31.

IEEE

[1]F. Aydemir ve M. Ebeoğlu, “A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point”, Journal of Science, Technology and Engineering Research, c. 2, sy 1, ss. 23–31, Haz. 2021, doi: 10.5281/zenodo.4698418.

ISNAD

Aydemir, Fırat - Ebeoğlu, Mehmet. “A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point”. Journal of Science, Technology and Engineering Research 2/1 (01 Haziran 2021): 23-31. https://doi.org/10.5281/zenodo.4698418.

JAMA

1.Aydemir F, Ebeoğlu M. A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point. Journal of Science, Technology and Engineering Research. 2021;2:23–31.

MLA

Aydemir, Fırat, ve Mehmet Ebeoğlu. “A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point”. Journal of Science, Technology and Engineering Research, c. 2, sy 1, Haziran 2021, ss. 23-31, doi:10.5281/zenodo.4698418.

Vancouver

1.Fırat Aydemir, Mehmet Ebeoğlu. A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point. Journal of Science, Technology and Engineering Research. 01 Haziran 2021;2(1):23-31. doi:10.5281/zenodo.4698418

Dergide yayınlanan çalışmalar

Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 (CC BY-NC-ND 4.0) Uluslararası Lisansı ile lisanslanmıştır.

A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point

Öz

Anahtar Kelimeler

A Single-Stage Smart Driver with Automatic Dimming Capability for Multiple LED Strings Biased from a Single Point

Abstract

Keywords

Kaynakça

Ayrıntılar

Birincil Dil

Konular

Bölüm

Yazarlar

Yayımlanma Tarihi

Gönderilme Tarihi

Kabul Tarihi

Yayımlandığı Sayı

DOI

IZ

Kaynak Göster