Adsorption of a Dye on Plant Based Adsorbent: An Optimization Study

Yıl 2023, Cilt: 10 Sayı: 1, 121 - 128, 31.05.2023

Erbil Kavcı

https://doi.org/10.35193/bseufbd.1179273

Öz

In this study, methylene blue was adsorbed using the adsorbent obtained from Rumex Crispus L. plant stems. Taguchi Experiment design was used to optimize the adsorption conditions. The optimized conditions in the study are temperature, initial concentration, pH, and particle size. ANOVA analysis was performed to determine the effectiveness of the parameters. From the results, optimum levels were determined as 20 oC for temperature, 120 mg/L for concentration, pH=6.5, -0.425 mm for particle size. The estimated amount of qt under optimum conditions was calculated as 65.58 mg/g. The most important contribution to the adsorption process by ANOVA analysis was pH with 62.8%, initial concentration with 29.6%, temperature with 5.4%, and particle size with 2.3%.

Anahtar Kelimeler

Adsorption, Methylene Blue, Optimization, Taguchi Methodology, ANOVA

Bitki Bazlı Adsorbent Üzerine Boyar Madde Adsorpsiyonu: Bir Optimizasyon Çalışması

Öz

Bu çalışmada Rumex Crispus L. bitki gövdelerinden elde edilen adsorbent üzerine metilen mavisi adsorbe edilmiştir. Adsorpsiyon şartlarını optimize edebilmek için Taguchi Deney tasarımı kullanılmıştır. Çalışmada optimize edilen şartlar: sıcaklık, başlangıç boya konsantrasyonu, pH ve tanecik boyutudur. Parametrelerin ne ölçüde etkin olduğunu belirlemek için ise ANOVA analizi yapılmıştır. Mevcut çalışmadan elde edilen sonuçlardan optimum şartlar; sıcaklık, 20 oC, başlangıç boya konsantrasyonu,120 mg/L, pH=6.5 ve tanecik boyutu 0.425 mm olarak tespit edilmiştir. Optimum şartlarda tahmin edilen qt miktarı 65.58 mg/g olarak hesaplanmıştır. ANOVA analizi ile adsorpsiyon prosesine en önemli katkıyı %62.8 ile pH, %29.6 ile başlangıç boya konsantrasyonu, %5.4 ile sıcaklık ve %2.3 ile tanecik boyutu sağlamıştır.

Anahtar Kelimeler

Adsorpsiyon, Metil Mavisi, Optimizasyon, Taguchi Metodu, ANOVA

Kaynakça

• Volkan, N., & Ozmetı̇n, E. (2022). Maxilon Blue GRL Boyar Maddesinin İllit Kil Minerali İle Gideriminin Optimizasyonu. Düzce Üniversitesi Bilim ve Teknoloji Dergisi, 10(1), 216-232. https://doi.org/10.29130/dubited.863992
• Namal, O. O., & Kalipci, E. (2019). Adsorption kinetics of methylene blue using alkali and microwave-modified apricot stones. Separation Science and Technology, 54(11), 1722-1738. https://doi.org/10.1080/01496395.2018.1541469
• Boughrara, L., Zaoui, F., Guezzoul, M., Sebba, F. Z., Bounaceur, B., & Kada, S. O. (2022). New alginic acid derivatives ester for methylene blue dye adsorption: Kinetic, isotherm, thermodynamic, and mechanism study. International Journal of Biological Macromolecules, 205, 651-663. https://doi.org/10.1016/j.ijbiomac.2022.02.087
• Katheresan, V., Kansedo, J., & Lau, S. Y. (2018). Efficiency of various recent wastewater dye removal methods: A review. Journal of Environmental Chemical Engineering, 6(4), 4676-4697. https://doi.org/10.1016/j.jece.2018.06.060
• Özdemir, Ç. S. (2019). Equilibrium, kinetic, diffusion and thermodynamic applications for dye adsorption with pinecone. Separation Science and Technology, 0(0), 1-9. https://doi.org/10.1080/01496395.2019.1565769
• Siddiqui, S. I., Rathi, G., & Chaudhry, S. A. (2018). Acid washed black cumin seed powder preparation for adsorption of methylene blue dye from aqueous solution: Thermodynamic, kinetic and isotherm studies. Journal of Molecular Liquids, 264, 275-284. https://doi.org/10.1016/j.molliq.2018.05.065
• Jawad, A. H., Abdulhameed, A. S., & Mastuli, M. S. (2020). Acid-factionalized biomass material for methylene blue dye removal: A comprehensive adsorption and mechanism study. Journal of Taibah University for Science, 14(1), 305-313. https://doi.org/10.1080/16583655.2020.1736767
• Afroze, S., Sen, T. K., Ang, M., & Nishioka, H. (2016). Adsorption of methylene blue dye from aqueous solution by novel biomass Eucalyptus sheathiana bark: Equilibrium, kinetics, thermodynamics and mechanism. Desalination and Water Treatment, 57(13), 5858-5878. https://doi.org/10.1080/19443994.2015.1004115
• Tang, Y., Zhao, Y., Lin, T., Li, Y., Zhou, R., & Peng, Y. (2019). Adsorption performance and mechanism of methylene blue by H3PO4- modified corn stalks. Journal of Environmental Chemical Engineering, 7(6), 103398. https://doi.org/10.1016/j.jece.2019.103398
• Nayak, A. K., & Pal, A. (2020). Utilization of Lignocellulosic Waste for Acridine Orange Uptake: Insights into Multiparameter Isotherms Modeling with ANN-Aimed Formulation. Journal of Environmental Engineering, 146(9), 04020096. https://doi.org/10.1061/(ASCE)EE.1943-7870.0001762
• Khare, P., & Kumar, A. (2012). Removal of phenol from aqueous solution using carbonized Terminalia chebula-activated carbon: Process parametric optimization using conventional method and Taguchi’s experimental design, adsorption kinetic, equilibrium and thermodynamic study. Applied Water Science, 2(4), 317-326. https://doi.org/10.1007/s13201-012-0047-0
• Rezaei, H., Haghshenasfard, M., & Moheb, A. (2017). Optimization of dye adsorption using Fe3O4 nanoparticles encapsulated with alginate beads by Taguchi method. Adsorption Science & Technology, 35(1-2), 55-71. https://doi.org/10.1177/0263617416667508
• Yılmaz, C. E., Aslani, M. A. A., & Aslani, C. K. (2019). Helianthus Annuus Çekirdeği Kabuklarında Toryum Sorpsiyonunun Taguchi Metodu Kullanılarak İncelenmesi. Dokuz Eylül Üniversitesi Mühendislik Fakültesi Fen ve Mühendislik Dergisi, 21(63), 741-747.
• Sohrabi, M. R., Khavaran, A., Shariati, S., & Shariati, S. (2017). Removal of Carmoisine edible dye by Fenton and photo Fenton processes using Taguchi orthogonal array design. Arabian Journal of Chemistry, 10, S3523-S3531. https://doi.org/10.1016/j.arabjc.2014.02.019
• Durán-Jiménez, G., Hernández-Montoya, V., Montes-Morán, M. A., Bonilla-Petriciolet, A., & Rangel-Vázquez, N. A. (2014). Adsorption of dyes with different molecular properties on activated carbons prepared from lignocellulosic wastes by Taguchi method. Microporous and Mesoporous Materials, 199, 99-107. https://doi.org/10.1016/j.micromeso.2014.08.013
• Pundir, R., Chary, G. H. V. C., & Dastidar, M. G. (2018). Application of Taguchi method for optimizing the process parameters for the removal of copper and nickel by growing Aspergillus sp. Water Resources and Industry, 20, 83-92. https://doi.org/10.1016/j.wri.2016.05.001
• Bayrak, B., Laçin, O., & Saraç, H. (2015). Ham Manyezit Cevherinin Glukonik Asit Çözeltilerinde çözündürülmeisnin Optimizasyonu. Anadolu Üniversitesi Bilim Ve Teknoloji Dergisi A - Uygulamalı Bilimler ve Mühendislik, 16(2), 195-202. https://doi.org/10.18038/btd-a.35162
• Zolgharnein, J., & Rastgordani, M. (2018). Optimization of simultaneous removal of binary mixture of indigo carmine and methyl orange dyes by cobalt hydroxide nano-particles through Taguchi method. Journal of Molecular Liquids, 262, 405-414. https://doi.org/10.1016/j.molliq.2018.04.038
• Santra, D., Joarder, R., & Sarkar, M. (2014). Taguchi design and equilibrium modeling for fluoride adsorption on cerium loaded cellulose nanocomposite bead. Carbohydrate Polymers, 111, 813-821. https://doi.org/10.1016/j.carbpol.2014.05.040
• Benkaddour, S., Slimani, R., Hiyane, H., El Ouahabi, I., Hachoumi, I., El Antri, S., & Lazar, S. (2018). Removal of reactive yellow 145 by adsorption onto treated watermelon seeds: Kinetic and isotherm studies. Sustainable Chemistry and Pharmacy, 10, 16-21. https://doi.org/10.1016/j.scp.2018.08.003
• Mashkoor, F., & Nasar, A. (2019). Preparation, characterization and adsorption studies of the chemically modified Luffa aegyptica peel as a potential adsorbent for the removal of malachite green from aqueous solution. Journal of Molecular Liquids, 274, 315-327. https://doi.org/10.1016/j.molliq.2018.10.119
• Kavci, E. (2021). Malahit yeşili boyar maddesinin çam kozalağı ile adsorpsiyonunun Taguchi metodu ile incelenmesi. Dokuz Eylül Üniversitesi Mühendislik Fakültesi Fen ve Mühendislik Dergisi, 23(67), 129-135. https://doi.org/10.21205/deufmd.2021236711
• Kazemi, S. Y., Biparva, P., & Ashtiani, E. (2016). Cerastoderma lamarcki shell as a natural, low cost and new adsorbent to removal of dye pollutant from aqueous solutions: Equilibrium and kinetic studies. Ecological Engineering, 88, 82-89. https://doi.org/10.1016/j.ecoleng.2015.12.020