TEKSTİL ATIKSUYUNDAN ASTRAZON BLACK BOYASININ GİDERİMİ: TAGUCHİ METODU İLE MODELLEME

Öz

Bu çalışmada, adsorbent olarak kullanılan bahçe toprağı ile sentetik olarak hazırlanan Astrazon Black MBL (AB) boyası giderimi araştırılmıştır. Araştırmada sentetik boya çözeltisinde hem renk hem de organik madde içeriğinin giderimi, adsorpsiyon ve Fenton prosesleri ile farklı işletme şartları altında çalışılmıştır. Arıtma sonrası numunelerde oksidasyon-redüksiyon potansiyeli (ORP) ve FTIR analizleri gerçekleştirilmiştir. Fenton prosesinde oluşan çamur miktarı ölçülmüş, her iki sistem için renk giderimi, KOİ giderimi ve ORP değişimi istatistiksel analiz edilerek modeller önerilmiştir. Adsorpsiyon çalışmasında renk ve KOİ giderimi için işletme parametrelerinin farklı etkisi ve elde edilen optimum değerler farklı olmuştur. Fenton çalışmasında ise Fe+2 ve H2O2 miktarı hem renk hem de KOİ giderimine aynı etkiye sahip olmuştur. Aynı optimum değerler elde edilmiş ve her iki sistem ile optimum şartlarda rengin tamamı giderilebilmiştir. Her iki sistemde de KOİ giderimi %86’nın üzerinde gerçekleşmiştir. Kullanılan toprak ile yüksek oranlarda renk giderilebileceği ve organik maddelerin yüzeyde tutunabileceği sonucuna varılmıştır.

Anahtar Kelimeler

• Adsorpsiyon
• Fenton
• Toprak
• Tekstil Atıksuyu
• Taguchi Metodu

REMOVAL OF ASTRAZON BLACK DYE FROM TEXTILE WASTEWATER: MODELLING BY TAGUCHI METHOD

Öz

In this study, both color and organic matter removal in Astrazon Black MBL (AB) dye wastewater were studied under different operation conditions by adsorption and Fenton processes. Moreover, oxidation-reduction potential (ORP) and FTIR analysis were performed on the samples after treatment. The amount of sludge generated in the Fenton process was measured. Color removal, chemical oxygen demand (COD) removal and ORP change for both systems were statistically analyzed and models were proposed using Taguchi method. As a result of the study, effects of operation parameters and optimum values obtained for color and COD removals in the adsorption study were different. In the Fenton study, the amount of Fe+2 and H2O2 had the same effect on both color and COD removals, and the same optimum values were obtained. With both systems, the color could completely be removed under optimum conditions. COD removal determined also over 86% for both systems. If the removal of both parameters is to be considered, the operation conditions of the process should be determined according to COD removal, since color removal is much easier than mineralization. The soil used as an adsorbent has shown that high levels of color and organic matters may be adsorbed.

Anahtar Kelimeler

• Adsorption
• Fenton
• Soil
• Textile Wastewater
• Taguchi Method

Kaynakça

1. Acevedo, B., Rocha, R.P., Pereira, M.F.R., Figueiredo, J.L., Barriocanal, C., 2015. Adsorption of Dyes by ACs Prepared from Waste Tyre Reinforcing Fibre. Effect of Texture, Surface Chemistry and pH. Journal of Colloid and Interface Science, 459, 189-198.
2. Adar, E., 2020. Optimization of Triple Dye Mixture Removal by Oxidation with Fenton. Int. J. Environ. Sci. Technol., 17, 4431-4440. https://doi.org/10.1007/s13762-020-02782-1.
3. Adar, E., Bilgili, M.S., 2015. The Performance of Four Different Mineral Liners on The Transportation of Chlorinated Phenolic Compounds to Groundwater in Landfills. The Scientific World Journal, 2015.
4. Aktas, D., Dizge, N., Yatmaz, H.C., Caliskan, Y., Ozay, Y., Caputcu, A. 2017. The Adsorption and Fenton Behavior of Iron Rich Terra Rosa Soil for Removal of Aqueous Anthraquinone Dye Solutions: Kinetic and Thermodynamic Studies. Water Science and Technology: A Journal of the International Association on Water Pollution Research, 76, 3114-3125.
5. Alalm-Gar, M., Nasr, M., 2018. Artificial Intelligence, Regression Model, and Cost Estimation for Removal of Chlorothalonil Pesticide by Activated Carbon Prepared from Casuarina Charcoal. Sustainable Environment Research, 28, 101-110.
6. APHA, 2012. American Public Health Association, Standart Methods for The Examination of Water and Wastewater, 21 Edt. Washington DC.
7. Babaei, A.A., Kakavandi, B., Rafiee, M., Kalantarhormizi, F., Purkaram, I., Ahmadi, E., Esmaeili, S., 2017. Comparative Treatment of Textile Wastewater by Adsorption, Fenton, UV-Fenton and US-Fenton Using Magnetic Nanoparticles-Functionalized Carbon (MNPs@C). Journal of Industrial and Engineering Chemistry, 56, 163-174.
8. Canbolat, Ç.B., 2019. Treatment of Membran Concentrates Using a New Technology Based on Hydrodynamic Cavitation and Advanced Oxidation Processes For Water and Salt Reuse From Textile Wastewater. PhD Thesis. Gebze Technical University, Kocaeli.

9. Çakmak, M., Taşar, Ş., Selen, V., Özer, D., Özer, A., 2017. Removal of Astrazon Golden Yellow 7GL from Colored Wastewater Using Chemically Modified Clay. Journal of Central South University, 24, 743-753.
10. Dinçer, A., Sevildik, M., Aydemir, T., 2019. Optimization, Isotherm and Kinetics Studies of Azo Dye Adsorption on Eggshell Membrane. International Journal of Chemistry and Technology, 3, 52-60.
11. Dindar, N., 2019. Implementation of Advanced Treatment Processes in Textile Industry Wastewaters for Organic Substance Removal. Master Thesis. Pamukkale University, Turkey. https://tez.yok.gov.tr/UlusalTezMerkezi/
12. Erat, N., 2018. Optimization of Removal of Astrazon Yellow 5GL Dye Material from Aqueous Media by Fenton and UV/H2O2 Processes Using Taguchi Method. Master Thesis. Ataturk University, Turkey. https://tez.yok.gov.tr/UlusalTezMerkezi/
13. Eren, Z., Acar, F.N., Ince, N.H., 2010. Fenton and Fenton-Like Oxidation of CI Basic Yellow 51: A Comparative Study. Coloration Technology, 126, 337-341.
14. Ertugay, N., Acar, F.N., 2017. Removal of COD and Color from Direct Blue 71 Azo Dye Wastewater by Fenton’s Oxidation: Kinetic Study. Arabian Journal of Chemistry, 10, S1158-S1163
15. Ertugay, N., 2018. The Removal of Crystal Violet (CV) Dyestuff by Wheat Bran: Kinetic Studies. Erzincan University Journal of Science and Technology, 11, 435-450.
16. Esteves, B.M., Rodrigues, C.S., Boaventura, R.A., Maldonado-Hodar, F.J., Madeira, L.M., 2016. Coupling of Acrylic Dyeing Wastewater Treatment by Heterogeneous Fenton Oxidation in a Continuous Stirred Tank Reactor with Biological Degradation in a Sequential Batch Reactor. Journal of Environmental Management, 166, 193-203.
17. Farah, J.Y., El-Gendy, N.S., 2007. Performance and Kinetic Studies on Biosorption of Astrazon Blue Dye by Dried Biomass of Baker’s Yeast as a Low Cost Biosorbent. Bioscience Biotechnology Research Asia, 4, 359-370.
18. Gao, J., Zhang, Q., Su, K., Chen, R., Peng, Y., 2010. Biosorption of Acid Yellow 17 from Aqueous Solution by Non-Living Aerobic Granular Sludge. Journal of Hazardous Materials, 174, 215-225.
19. GilPavas, E., Dobrosz-Gomez, I., Gomez-Garcia, M.A., 2019. Optimization and Toxicity Assessment of a Combined Electrocoagulation, H2O2/Fe(2+)/UV and Activated Carbon Adsorption for Textile Wastewater Treatment. The Science of the Total Environment, 651, 551-560.
20. Güneş, E., Cihan, M.T., 2015. COD and Color Removal from Wastewaters: Optimization of Fenton Process. Pamukkale University Journal of Engineering Sciences, 21, 239-247.
21. Ilhan, F., Yetilmezsoy, K., Kabuk, A., Ulucan, K., Coskun, T., Akoglu, B., 2017. Evaluation of Operational Parameters and Its Relation on The Stoichiometry of Fenton’s Oxidation to Textile Wastewater. Chemical Industry and Chemical Engineering Quarterly, 23, 11-19
22. Illes, E., Mizrahi, A., Marks, V., Meyerstein, D., 2019. Carbonate-Radical-Anions, and not Hydroxyl Radicals, are The Products of the Fenton Reaction in Neutral Solutions Containing Bicarbonate. Free Radical Biology & Medicine, 131, 1-6.
23. Kavitha, V., Palanivelu, K., 2005. Destruction of Cresols by Fenton Oxidation Process. Water Research, 39, 3062-3072
24. Khamparia, S., Jaspal, D., 2016. Adsorptive Removal of Direct Red 81 Dye from Aqueous Solution onto Argemone Mexicana. Sustainable Environment Research, 26, 117-123.
25. Khan, J., Tariq, M., Muhammad, M., H. Mehmood, M., Ullah, I., Raziq, A., Akbar, F., Saqib, M., Rahim, A., Niaz, A., 2019. Kinetic and Thermodynamic Study of Oxidative Degradation of Acid Yellow 17 Dye by Fenton-Like Process: Effect of HCO3−, CO32−, Cl− and SO42− on Dye Degradation. Bulletin of the Chemical Society of Ethiopia, 33, 243.
26. Lee, J.J., 2016. Equilibrium, Kinetic and Thermodynamic Parameter Studies on Adsorption of Acid Yellow 14 Using Activated Carbon. Korean Chemical Engineering Research, 54, 255-261.
27. Li, F., Fang, X., Zhou, Z., Liao, X., Zou, J., Yuan, B., Sun, W., 2019. Adsorption of Perfluorinated Acids onto Soils: Kinetics, Isotherms, and Influences of Soil Properties. The Science of the Total Environment, 649, 504-514.
28. Marungrueng, K., Pavasant, P., 2006. Removal of Basic Dye (Astrazon Blue FGRL) Using Macroalga Caulerpa Lentillifera. Journal of Environmental Management, 78, 268-274.
29. Matavos-Aramyan, S., Moussavi, M., 2017. Advances in Fenton and Fenton Based Oxidation Processes for Industrial Effluent Contaminants Control—A Review. Int. J. Environ. Sci. Nat. Resour, 2, 1-18
30. Oyekanmi, A.A., Ahmad, A., Hossain, K., Rafatullah, M., 2019. Statistical Optimization for Adsorption of Rhodamine B Dye from Aqueous Solutions. Journal of Molecular Liquids, 281, 48-58.
31. Öztürk, M., Yildiz, S., Aslan, Ş., 2020. Nikel (Ii) İyonlarinin Atik Çay’a Biyosorpsiyonu: Denge, Kinetik ve Termodinamik Çalişmalari. Mühendislik Bilimleri ve Tasarım Dergisi, 8(4), 985-998.
32. Papić, S., Vujević, D., Koprivanac, N., Šinko, D., 2009. Decolourization and Mineralization of Commercial Reactive Dyes by Using Homogeneous and Heterogeneous Fenton and UV/Fenton Processes. Journal of Hazardous Materials, 164, 1137-1145.
33. Rahman, M.M., Yusuf, M.A., Uddin, M.A., Islam, M.A., Saha, R., Rahman, M.M., Haque, M.A., Hasnat, M.A., 2010. Influence of Irradiation on Fenton Degradation of Brilliant Red X-3B. International Journal of Chemical Reactor Engineering, 8.
34. Rodrigues, C.S., Boaventura, R.A., Madeira, L.M., 2012. Application of Fenton´s Reagent for Acrylic Dyeing Wastewater Decolorization, Organic Matter Reduction and Biodegradability Improvement. Journal of Advanced Oxidation Technologies, 15, 78-88.
35. Rosales, E., Anasie, D., Pazos, M., Lazar, I., Sanroman, M.A., 2018. Kaolinite Adsorption-Regeneration System for Dyestuff Treatment by Fenton Based Processes. The Science of the Total Environment, 622-623, 556-562.
36. Schrank, S.G., dos Santos, J.N.R., Souza, D.S., Souza, E.E.S., 2007. Decolourisation Effects of Vat Green 01 Textile Dye and Textile Wastewater Using H2O2/UV Process. Journal of Photochemistry and Photobiology A: Chemistry, 186, 125-129.
37. Sennaoui, A., Alahiane, S., Sakr, F., Assabbane, A., Addi, E.H.A., Hamdani, M., 2018. Advanced Oxidation of Reactive Yellow 17 Dye: A Comparison between Fenton, Photo-Fenton, Electro-Fenton, Anodic Oxidation and Heterogeneous Photocatalysis Processes. Portugaliae Electrochimica Acta, 36,163-178.
38. Serencam, H., Ucurum, M., 2019. Performance Evaluation of Adsorption Properties for Ni(II) Removal with Flying Ash Using Taguchi Experimental Design. Omer Halisdemir University Journal of Engineering Sciences, 8(1), 336-344.
39. Son-Dang, B.H., Quang-Mai, V., Xuan-Du, D., Hai-Phong, N., Quang-Khieu, D., 2016. A Study on Astrazon Black AFDL Dye Adsorption onto Vietnamese Diatomite. Journal of Chemistry, 2016, 1-11.
40. Teli, M.D., Nadathur, G.T., 2018. Adsorptive Removal of Acid Yellow 17 (An Anionic Dye) from Water by Novel Ionene Chloride Modified Electrospun Silica Nanofibers. Journal of Environmental Chemical Engineering, 6, 7257-7272.
41. Tezcan-Bayrak, E., Ceylan, Z., Acar, F.N., 2019. Kinetics, Isotherm and Thermodynamic Studies of the Adsorption Behavior of Basic Yellow 51 onto Rice Husk and Burned Rice Husk. Journal of the Institute of Science and Technology, 9(4), 1977-1988.
42. Tony, M.A., Parker, H.L., Clark, J.H., 2019. Evaluating Algibon Adsorbent and Adsorption Kinetics for Launderette Water Treatment: Towards Sustainable Water Management. Water and Environment Journal, 33, 401-408.
43. Tunc, S., Gürkan, T., Duman, O., 2012. On-line Spectrophotometric Method for The Determination of Optimum Operation Parameters on The Decolorization of Acid Red 66 and Direct Blue 71 From Aqueous Solution by Fenton Process. Chemical Engineering Journal, 181-182, 431-442.
44. Türkeş, S., 2019. Investigation of the Treatability of Textile Industry Wastewaters with Fenton and Photo-Fenton Processes. Master Thesis. Çukurova University, Adana, Turkey.
45. Türkyilmaz, A., Işinkaralar, K., 2020. Sulu Çözeltilerden Aktif Karbon Üzerine Adsorpsiyon ile Antibiyotiklerin (Tetrasiklin ve Penisilin G) Giderimi. Mühendislik Bilimleri ve Tasarım Dergisi, 8(3), 943-951.
46. Wu, H., Wang, S., 2012. Impacts of Operating Parameters on Oxidation-Reduction Potential and Pretreatment Efficacy in The Pretreatment of Printing and Dyeing Wastewater by Fenton Process. Journal of Hazardous Materials, 243, 86-94.
47. Wu, Y., Zhou, S., Qin, F., Ye, X., Zheng, K., 2010. Modeling Physical and Oxidative Removal Properties of Fenton Process for Treatment of Landfill Leachate Using Response Surface Methodology (RSM). Journal of Hazardous Materials, 180, 456-465.
48. Yu, R.F., Chen, H.W., Cheng, W.P., Lin, Y.J., Huang, C.L., 2014. Monitoring of ORP, pH and DO in Heterogeneous Fenton Oxidation Using NZVI as a Catalyst for The Treatment of Azo-Dye Textile Wastewater. Journal of the Taiwan Institute of Chemical Engineers, 45(3), 947-954.