ÜZÜM, NAR VE KARA HAVUÇ SULARININ FARKLI YÖNTEMLERLE KONSANTRASYONUNUN MATEMATİKSEL MODELLENMESİ

Öz

Bu çalışmada başlangıç °Briks değerleri sırasıyla 15.93, 13.91 ve 11.23 olan üzüm, nar ve siyah havuç suları 65 °Briks değerine kadar konsantre edilmiştir. Meyve sularının konsantrasyon kinetik değerleri rotary vakum evoparatörde 80 ˚C’de, mikrodalga vakum evaporatörde 180 ve 300 W’da, ozmotik distilasyonda ise oda sıcaklığında çalışılarak belirlenmiştir. Elde edilen deneysel verilerin 13 farklı modele uygunluğu, korelasyon katsayısı (R²), azaltılmış ki-kare (χ2) değeri ve hata kareler ortalamasının karekökü (RMSE) olmak üzere 3 istatistiksel parametreye göre karşılaştırılmıştır. Konsantrasyon kinetiği açısından Midilli modeli (R² ≥ 0.9990; χ² ≤ 0.4588; RMSE ≤ 0.5350) diğer modellerden genel olarak daha uyumlu bulunmuş olup, bu modeli logaritmik, Page ve iki terimli eksponansiyel modelleri izlemiştir. Termal konsantrasyon yöntemi için logaritmik modelin Midilli modeline göre daha uyumlu olduğu görülmüştür. En düşük enerji tüketimi (1.334-1.540 kWh) ise ozmotik distilasyon tekniğinde belirlenmiştir.  

Anahtar Kelimeler

• Meyve suyu konsantrasyonu,matematiksel modelleme,mikrodalga vakum evoparasyon,ozmotik distilasyon

MATHEMATICAL MODELING OF CONCENTRATIONS OF GRAPE, POMEGRANATE AND BLACK CARROT JUICES BY VARIOUS METHODS

Öz

In the present study, grape, pomegranate and black carrot juices were concentrated to 65 °Brix (Bx) from initial concentrations of 15.93, 13.91 and 11.23 °Bx respectively. The concentration kinetics of the juices were investigated using a rotary vacuum evaporator at 80°C, a microwave vacuum evaporator at 180 W and 300 W and osmotic distillation (OD) at room temperature. Experimental data were compared according to three statistical parameters: the correlation coefficient (R²), reduced chi-squared (χ2) value, and root mean-square error (RMSE), with values predicted by 13 models. Midilli model exhibited a better fit for the concentration kinetics (R² ≥ 0.9990; χ² ≤ 0.4588; RMSE ≤ 0.5350) than the other models, in general. This model was followed by the logarithmic, Page and two-term exponential models. The logarithmic model exhibited slightly better fitting for the thermal concentration method than Midilli model. The lowest energy consumption (1.334-1.540 kWh) was determined for the OD technique.

Anahtar Kelimeler

• Juice concentration,mathematical modeling,microwave vacuum evaporation,osmotic distillation

Kaynakça

1. 1. Jiao B, Cassano A, Drioli E. Recent advances on membrane processes for the concentration of fruit juices: a review. J. Food Eng. 2004; 63(3), 303-324. https://doi.org/10.1016/j.jfoodeng.2003.08.003
2. 2. Bánvölgyi S, Horváth S, Stefanovits-Bányai É, Békássy-Molnár E, Vatai G. Integrated membrane process for blackcurrant (Ribes nigrum L.) juice concentration. Desalination 2009; 241(1-3), 281-287. https://doi.org/10.1016/j.desal.2007.11.088
3. 3. Dincer C, Tontul I, Topuz A A comparative study of black mulberry juice concentrates by thermal evaporation and osmotic distillation as influenced by storage. Innovative Food Sci. Emerg. Technol. 2016; 38, 57-64. https://doi.org/10.1016/j.ifset.2016.09.012
4. 4. Bozkir H, Baysal T. Concentration of apple juice using a vacuum microwave evaporator as a novel technique: Determination of quality characteristics. J. Food Process Eng. 2017; 40(5), e12535. https://doi.org/10.1111/jfpe.12535
5. 5. Assawarachan R, Noomhorm A. Effect of operating condition on the kinetic of color change of concentrated pineapple juice by microwave vacuum evaporation. J. Food Agric. Environ, 2008; 6(3&4), 47-53.
6. 6. Assawarachan R, Noomhorm A. Mathematical models for vacuum‐microwave concentration behavior of pineapple juice. J. Food Process Eng, 2011; 34(5), 1485-1505. https://doi.org/10.1111/j.1745-4530.2009.00536.x
7. 7. Fazaeli M, Hojjatpanah G, Emam-Djomeh Z. Effects of heating method and conditions on the evaporation rate and quality attributes of black mulberry (Morus nigra) juice concentrate. J. Food Sci. Technol. 2013; 50(1), 35-43. https://doi.org/10.1007/s13197-011-0246-y
8. 8. Fazaeli M, Yousefi S, Emam-Djomeh Z. Investigation on the effects of microwave and conventional heating methods on the phytochemicals of pomegranate (Punica granatum L.) and black mulberry juices. Food Res. Int. 2013; 50(2), 568-573. https://doi.org/10.1016/j.foodres.2011.03.043

9. 9. Yousefi S, Emam-Djomeh Z, Mousavi S M A, Askari G R. Comparing the effects of microwave and conventional heating methods on the evaporation rate and quality attributes of pomegranate (Punica granatum L.) juice concentrate. Food Bioprocess Technol. 2012; 5(4), 1328-1339. https://doi.org/10.1007/s11947-011-0603-x
10. 10. Assawarachan R, Noomhorm A. Changes in color and rheological behavior of pineapple concentrate through various evaporation methods. Int. J. Agric. Biol. Eng. 2010; 3(1), 74-84.
11. 11. Yaldýz O, Ertekýn C. Thin layer solar drying of some vegetables. Drying Technol. 2001; 19(3-4), 583-597. https://doi.org/10.1081/DRT-100103936
12. 12. Delgado T, Pereira J A, Baptista P, Casal S, Ramalhosa E. Shell's influence on drying kinetics, color and volumetric shrinkage of Castanea sativa Mill. fruits. Food Res. Int. 2014; 55, 426-435. https://doi.org/10.1016/j.foodres.2013.11.043
13. 13. Demiray E, Tulek Y. Drying characteristics of garlic (Allium sativum L) slices in a convective hot air dryer. Heat Mass Transfer. 2014; 50(6), 779-786. https://doi.org/10.1007/s00231-013-1286-9
14. 14. Malekjani N, Emam-Djomeh Z, Hashemabadi S H, Askari G R. Modeling Thin Layer Drying Kinetics, Moisture Diffusivity and Activation Energy of Hazelnuts during Microwave-Convective Drying. Int. J. Food Eng. 2018;14(2). https://doi.org/10.1515/ijfe-2017-0100
15. 15. Karabacak, A. Ö., Suna, S., Tamer, C. E., Çopur, Ö. U. Effects of oven, microwave and vacuum drying on drying characteristics, colour, total phenolic content and antioxidant capacity of celery slices. Qual. Assur. Saf. Crops Food 2018; 10(2), 193-205. https://doi.org/10.3920/QAS2017.1197
16. 16. Goula A M, Tzika A, Adamopoulos K G. Kinetic Models of Evaporation and Total Phenolics Degradation during Pomegranate Juice Concentration. Int. J. Food Eng 20104; 10(3), 383-392. https://doi.org/10.1515/ijfe-2014-0016
17. 17. Kırca A, Özkan M, Cemeroglu B. Stability of black carrot anthocyanins in various fruit juices and nectars. Food Chem. 2006; 97(4), 598-605. https://doi.org/10.1016/j.foodchem.2005.05.036
18. 18. Tajchakavit S, Boye J I, Bélanger D, Couture R. Kinetics of haze formation and factors influencing the development of haze in clarified apple juice. Food Res. Int. 2001; 34(5), 431-440. https://doi.org/10.1016/S0963-9969(00)00188-5
19. 19. Cissé M, Vaillant F, Bouquet S, Pallet D, Lutin F, Reynes M, Dornier M. Athermal concentration by osmotic evaporation of roselle extract, apple and grape juices and impact on quality. Innovative Food Sci. Emerg. Technol. 2011; 12(3), 352-360. https://doi.org/10.1016/j.ifset.2011.02.009
20. 20. Onsekizoglu P. Production of high quality clarified pomegranate juice concentrate by membrane processes. J. Membr. Sci. 2013; 442, 264-271. https://doi.org/10.1016/j.memsci.2013.03.061
21. 21. Romero J, Rios G M, Sanchez J, Bocquet S, Savedra A. Modeling heat and mass transfer in osmotic evaporation process. AlChE J. 2003; 49(2), 300-308. https://doi.org/10.1002/aic.690490203
22. 22. Valdés H, Romero J, Saavedra A, Plaza A, Bubnovich V. Concentration of noni juice by means of osmotic distillation. J. Membr. Sci. 2009; 330(1-2), 205-213. https://doi.org/10.1016/j.memsci.2008.12.053
23. 23. Onsekizoglu Bagci P. Potential of membrane distillation for production of high quality fruit juice concentrate. Crit. Rev. Food Sci. Nutr. 2015; 55(8), 1098-1113. https://doi.org/10.1080/10408398.2012.685116
24. 24. Midilli A, Kucuk H, Yapar Z. A new model for single-layer drying. Drying Technol. 2002; 20(7), 1503-1513. https://doi.org/10.1081/DRT-120005864
25. 25. Swain S, Samuel D V K, Bal L M, Kar A, Sahoo G P. Modeling of microwave assisted drying of osmotically pretreated red sweet pepper (Capsicum annum L.). Food Sci. Biotechnol. 2012; 21(4), 969-978. https://doi.org/10.1007/s10068-012-0127-9
26. 26. Vega‐Gálvez A, Lemus‐Mondaca R, Bilbao‐Sainz C, Yagnam F, Rojas A. Mass transfer kinetics during convective drying of red pepper var. Hungarian (Capsicum annuum L.): mathematical modeling and evaluation of kinetic parameters. J. Food Process Eng. 2008; 31(1), 120-137. https://doi.org/10.1111/j.1745-4530.2007.00145.x